2022年安装工程监理实施细则 .pdf

监理实施细则（安装部分）编制：审批：建设项目管理有限公司二一一年八月目录消防系统监理实施细则给排水安装工程监理实施细则电气安装工程监理实施细则文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3消防工程安装监理实施细则一、工程概况1、工程建设地点:2、建筑面积:92000m2，0.000 相当于绝对高程 00000m。本工程用地范围整体为两层地下室，上部由5 栋高层（17 层），4 栋裙房（3 层），共 9 栋单体建筑组成；东面为大街，南临大路，西面为铁路小区 1、2 宿舍，北面为铁路小区新区。3、主要功能：本工程为商住楼，其中一、二、三层为商业裙房，四层至十七层为住宅，地下室一、二层为整体地下车库共设310 个车位。4、基础形式：人工挖孔灌注桩筏板结构；建筑结构型式：框架剪力墙结构，抗震设防烈度：七度；建筑耐火等级：一级；设计使用年限 50 年。5、各参建单位：建设单位：房地产开发有限公司设计单位：轻纺工业设计院勘察单位：工程勘察公司施工单位：建筑集团有限公司监理单位：建设项目管理有限公司6、工程质量要求：达到国家现行验收规范的合格等级合同工期要求：按招投标和施工承发包合同安全施工要求：按招投标和施工承发包合同安全施工要求造价控制要求：按招投标文件及施工承发包合同二、编制依据1、相关技术标准、质量验收规范2、建设工程监理规范（GB50319-2000）3、委托监理合同、施工承包合同4、本工程的监理规划5、施工图设计文件（包括图纸会审纪要、设计交底文件及设计变更文件等）6、已审查批准的施工组织设计或专项施工方案7、其他相关文件资料三、设计要求（详见图纸说明）。四、目标分解文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3根据监理规划质量目标要求及工程内容进行分解：1、管道及配件安装达到合格；2、设备安装达到合格；3、管道防腐达到合格；4、消防系统附件及配件安装达到合格；5、消防系统调试达到合格；6、管道压力试验及管道冲洗达到合格。五、施工难点及监理要点1、施工难点（1）管件接头处理；（2）安装过程中的交叉配合；（3）系统试压、调试。2、监理要点（1）见证点：材料、构配件等必须经认可方能进场；（2）停止点：管道施工完毕，必须经水压试验、闭水试验和系统冲洗并合格后，方可进行封闭及进行下一道工序。六、预控要点（一）施工单位资质的审查1、分包单位的营业执照、企业资质等级证书、特殊行业施工许可证、国外（境外）企业在国内承包工程许可证。2、分包单位的业绩。3、拟分包工程的内容和范围。4、专职管理人员和特种作业人员的资格证、上岗证。（二）对施工组织设计的审查1、质量管理、技术管理和质量保证的组织机构。2、质量管理、技术管理制度。3、施工组织方案措施。（三）原材料选择及其质量控制（四）施工单位每道工序开始施工前的技术交底工程每道工序开始前，监理工程师应参加施工单位对施工人员进行的技术交底。监理工程师应明确该工序的施工难点、见证点、停止点及常见工程质量通病。七、过程控制要点(一)消防系统材料质量控制1、消防灭火系统所使用的主要材料、成品、半成品、配件、器具和设备必须具有中文质量合格证明文件，并应具有出厂合格证及产文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3品准销证；规格、型号及性能检测报告应符合国家技术标准或设计要求。所有材料进场应进行检查验收，经监理工程师核查确认合格后，签发材料进场报验单。2、所有材料进场时应对品种、规格、外观等进行验收。包装应完好，表面无划痕及外力冲击破损。3、主要器具和设备必须有完整的安装使用说明书。在运输、保管和施工过程中，应采取有效措施防止损坏或腐蚀。4、管材、管件及配件表面质量检查：无裂纹、缩孔、夹渣、拆迭、重皮、砂眼、针孔和超过壁厚允许的局部凹坑、碰伤；镀锌钢管内外表的镀锌层不得有脱落、锈蚀等现象；螺纹密封面应完整，无损伤、无毛剌；非金属密封垫片应质地柔韧，无老化变质或分层现象，表面应无折损、皱纹等缺陷；法兰密封面应完整光洁，不得有毛剌及径向沟槽；螺纹法兰的螺纹应完整，无损伤。5、管道上使用冲压弯头时，所使用的冲压弯头外径应与管道外径相同。6、消防泵、消防栓、水泵接合器、喷头、报警阀、压力开关、水流指示器等主要系统组件应经国家消防产品质量监督检测中心检验合格；（1）喷头的现场检验应符合下列要求：喷头的型号、规格应符合设计要求；喷头的商标、型号、公称动作温度、制造厂及生产年月等标志应齐全；喷头外观，应无加工缺陷和机械损伤；喷头螺纹密封面应无伤痕、毛剌、缺丝或断丝的现象；闭式喷头应进行性能试验，并以无渗漏、无损伤为合格。试验数量宜从每批抽查1，但不得少于 5 只，试验压力为 3.0Mpa；试验时间不少于3min。当有 2 只及以上不合格时，不得使用这批喷头。当仅有一只不合格，应再抽查2，但不得少于10 只，重新进行密封性能试验，当仍有不合格时，亦不得使用该批喷头。（2）阀门及附件的现埸检验应符合下列要求：阀门的型号、规格应符合设计要求；阀门及其附件应配备齐全，不得有加工缺陷和机械损伤；报警阀除应有商标、型号、规格等标志外，尚应有水流方向永久性标志；报警阀和控制阀的阀瓣及操作机构应动作灵活，无卡涩现象；阀体内应清洁，无异物堵塞；报警阀应逐个进行渗漏试验，试验压力应为2 倍额定工作压力，试验时间为 5min，阀瓣处应无渗漏；文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3水力警铃的铃锤应转动灵活，无阻滞现象。（3）压力开关、水流指示器及水位、气压、阀门限位等自动监测装置应有清晰的铭牌。安全操作标志和产品说明书。水流指示器尚应有水流方向的永久性标志；安装前应逐个进行主要功能检查，不合格者不得使用。（4）消防栓箱开孔位置附合栓口安装的需要，箱体应无损伤、脱漆及变形情况。7、阀门安装前，应做强度和严密性试验。试验应在每批（同牌号、同律号、同规格）数量中抽查10，且不少于一个。对于安装在主干管?起切断作用的闭藯阀门，应逐个做强度和严密性试验。试验应符合以下规定：阀门的强度试验压力为公称压力的1.5 倍；严密性试验压力为公称压力的 1.1 倍；试验压力在试验持续时间内应保持不变，且壳体填料及阀瓣密封面无渗漏。阀门试压的试验持续时间应不少于下表的规定：阀门试压的试验持续时间表公称直径 DN（mm）最短试验持续时间（S）严密性试验强度试验金属密封非金属密封50 15 15 15 65200 30 15 60 250450 60 30 180（二）管道及其配件、附件安装1、管道预留、预埋（1）工程部分管道需要穿梁、穿墙、穿楼板安装。为保证施工质量，提高工作效率，对需穿梁、墙、楼板安装的管道应采取预埋套管或预留孔洞进行施工。其尺寸设计无规定时，应按下列规定执行：预留孔洞尺寸宜较管外径大50100。预埋套管时：给 水 管 径：DN（）150 125 100 80 65 50 套 管 直 径：（）200 175 160 130 110 90 安装在楼板内的套管，其顶部应高出装饰地面20mm；安装在文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3卫生间及厨房内的套管，其顶部应高出装饰地面50mm，底部应与楼板底面相平；安装在墙壁内的套管其两端与饰面相平。穿过楼板的套管与管道之间缝隙应用阻燃密实材料和防水油膏填实，端面光滑。穿墙套管与管道之间缝隙宜用阻燃密实材料填实，且端面应光滑。管道的接口不得设在套管内。给水管穿屋面时，必须采用钢套管。套管应高出屋面不少于100mm，并采用严格的防水措施。预埋套管及孔洞的预留工作要配合土建施工进行，并且要与设计图的位置、标高进行核对，经监理核实无误并签证后，才能实施下步工序。（2）地下室或地下构筑物外墙有管道穿过的，应采取防水措施。对有严格防水要求的建筑物，必须采取柔性防水套管。2、管道及其配件、附件安装过程的质量控制（1）操作工艺流程：安装准备预制加工（预留套管、孔洞）干管安装立管安装支管安装管道试压管道冲洗管道防腐（2）管道支、吊、托架的制作要求见S161标准图集，其安装应符合下列规定：1 位置正确，埋设应平整牢固。2 固定支架与管道接触应紧密，固定应可靠。3 滑动支架应灵活，滑托与滑槽两侧间应留有35mm 间隙，纵向移动量应符合设计要求。4 无热伸长管道的吊架、吊杆应垂直安装。5 固定在建筑结构上的管道支、吊、托架不得影响结构的安全。6 钢管水平安装的支、吊架间距不应大于下表的规定：DN（）15 20 25 40 50 70 80 100 125 150 200 250 间距（m）2.5 3.0 3.5 4.5 5.0 6.0 6.0 6.5 7.0 8.0 9.5 11 7 立管管卡安装应符合下列规定：A、楼层高度小于或等于5m，每层必须安装1 个。B、楼层高度大于 5m，每层不得少于2 个。C、管卡安装高度，距地面应为1.51.8m，2 个以上管卡应均称安装，同一房间管卡应安装在同一高度上。文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码:CF9F8P5V10O3 HG7O4B10C2O7 ZJ9H2H10W6U3文档编码: