MPW张紧绞车备件手册(PLC版).docx

MPW 张紧绞车备件手册北京山潜天恒科技MPW 张紧绞车备件手册说明1、零件件号以 MPWEXXX，MPWMXXX，MPWCXXX，MPWHXXX，MPWGXXX 为标准格式进展编制。其中：E 代表电器零部件，M 代表机械零部件，C 代表水冷系统零部件，H 代表液压站零部件，G 代表减速机零部件2、手册中各图片均为示意图，仅供参考，最终以实际产品为准3、如由于产品技术改造或升级造成的产品外观和零部件数量的更改会在最版本的手册中进展更4、用户如需选购手册中零部件，请与 北京山潜天恒科技销售人员联系联系 ： 010-88203446 ：010-88202317Email： yhzhoumountainpeak .cn1序号件号名称单台数量备注1MPW-E-001绞车主电机12MPW-E-074A主电机风扇1版本电机3MPW-E-074B主电机风扇1旧版本电机4MPW-M-001主电机底座15MPW-M-002主电机安装螺栓组8 组紧固主电机和底座- 2 -序号件号名称单台数量备注1MPW-M-003电机侧联轴器12MPW-M-004减速机侧联轴器13MPW-M-005弹性联轴器销轴8配螺母、平垫、弹垫4MPW-M-006弹性体4×8- 3 -序号件号名称单台数量备注序号件号名1MPW-M-007Brevini 减速机+制18MPW-M-016轴承座动器2MPW-M-010减速机侧支板19MPW-M-017轴承座3MPW-M-011轴承侧支板110MPW-M-018栓轴承座4MPW-M-012卷筒轴111MPW-M-023钢丝绳5MPW-M-013轴承座112MPW-M-024U 型螺6MPW-M-014轴承座盖17MPW-M-015轴承座盖密封圈1内部序号件号名称单台数量备注1MPW-M-008减速机花键套12MPW-M-009MPW 绞车卷筒13MPW-M-019卷筒轴承14MPW-M-020轴承紧定套1 组5MPW-M-021卷筒轴锁紧组件1 组6MPW-M-022花键套紧固螺栓12 组紧固花键套和卷筒5序号件号名称单台数量备注1MPW-M-025减速机紧固螺栓28 组紧固减速机和支板2MPW-M-026张力计1序号件号名称数量备注序号件号名1MPW-M-029主电控箱体19MPW-M-036圆柱销2MPW-M-030主电控箱大门110MPW-M-037开口销3MPW-M-031主电控箱小门111MPW-M-038紧固螺4MPW-M-032隔爆腔盖112MPW-M-042门体紧5MPW-M-033主电控箱底座113MPW-M-043箱体紧6MPW-M-034冷却系统支架114MPW-M-044隔爆腔7MPW-M-035冷却系统支架盖115MPW-E-055冷却系8MPW-E-054主电控箱与底座联结螺栓4底座联序号件号名称单台数量备注序号件号名称1MPW-E-002M50 防爆接头2参考实际数目6MPW-E-007M25 防爆2MPW-E-003M40 防爆接头3参考实际数目7MPW-E-132M32 防爆3MPW-E-004M40 防爆堵头2参考实际数目4MPW-E-005M32 防爆接头4参考实际数目5MPW-E-006M25 防爆接头3参考实际数目序号件号名称单台数量备注1MPW-E-029变频器12MPW-E-030模拟 I/O 扩展模块13MPW-E-031变频器通信模块14MPW-E-042变频器安装螺栓45MPW-E-032主电压器16MPW-E-034操作显示屏17MPW-E-035操作显示屏支架1配安装螺钉 4 组8MPW-E-044主电压器安装螺栓4 组紧固主变压器19序号件号名称单台数量备注1MPW-C-001卧式水泵+底座12MPW-C-002水泵电机13MPW-C-003安装法兰24MPW-C-004安装法兰胶垫25MPW-C-005电机安装螺栓组4 组安装水泵电机和底座6MPW-C-006底座紧固螺栓组4 组安装水泵底座和支架序号件号名称单台数量备注1MPW-C-007散热器12MPW-C-008散热器支架23MPW-C-009散热风扇+安装座1 组4MPW-C-010风扇电机15MPW-C-011支架安装螺栓4 组6MPW-C-012散热器安装螺栓4 组7MPW-C-013风扇电机安装螺栓4 组8MPW-C-014水管7-8m图中未作出9MPW-C-015水管卡子6图中未作出序号件号名称单台数量备注1MPW-E-008MPW 主电控板12MPW-E-010关心电机断路器23MPW-E-011变频器断路器14MPW-E-014关心电机接触器25MPW-E-227母线排1连接两个断路器6MPW-E-013浪涌抑制器(压敏电阻型)2位于接触器上7MPW-E-025关心触头2位于断路器上8MPW-E-026接触器安装适配器2连接断路器和接触器9MPW-E-01524V(5A)直流电源110MPW-E-11324V(2A)DC 电源1序号件号名称单台数量备注11MPW-E-237本安型 DI 安全栅612MPW-E-238本安型 DO 驱动型安1全栅13MPW-E-239本安型电源型安全1栅14MPW-E-240本安型 AI 型安全栅115MPW-E-036漏电线圈216MPW-E-111二路空开117MPW-E-200中间继电器318MPW-E-017漏电继电器219MPW-E-019PLC 掌握器120MPW-E-020PLC 状态量输入模块121MPW-E-028Modbus 电缆122MPW-E-109线槽3m依据需要制作23MPW-E-110导轨3m依据需要制作24MPW-E-089端子 UK5N RD1525MPW-E-088端子 UK5N8626MPW-E-120隔离端子 E/NS 35 N1227MPW-E-091端子挡片2228MPW-E-124短接片729MPW-E-022紧固螺钉3030MPW-E-023电控板紧固螺钉431MPW-E-136二极管1注：内部接线端子图中为示意序号件号名称单台数量备注1MPW-E-315主断路器12MPW-E-316主断路器支架1345678隔爆接线腔内部端子布置图序号件号名称单台数量备注1MPW-E-088端子 UK5N162MPW-E-091挡片 D-UK 4/1063MPW-E-095接地端子 USLKG 3514MPW-E-096端子 UK 3535MPW-E-098接地端子 USLKG 5016MPW-E-099端子 UKH 5037MPW-E-120隔离端子 E/NS 35 N68MPW-E-121隔离端子 E/AL NS 35 N3铝质9MPW-E-124短接片2序号件号名称单台数量备注1MPW-E-057就地掌握箱12MPW-E-058就地掌握箱内部电控板13MPW-E-060weiland 48 路底开放底座14MPW-E-128weiland 48 芯外罩1未做出5MPW-E-062weiland 24 芯插座16MPW-E-262weiland 24 芯插针17MPW-E-047红色急停按钮18MPW-E-064三位选择开关19MPW-E-050指示灯110MPW-E-049黑色功能按钮111MPW-E-067黄色功能按钮212MPW-E-068大张力显示屏1显示屏以箱体尺13MPW-E-268小张力显示屏1寸确定14MPW-E-071尼龙电缆接头515MPW-E-073底座紧固螺钉4 组16MPW-E-112门锁117MPW-E-127标牌2就地掌握箱内部面板端子序号件号名称单台数量备注1MPW-E-088接线端子 UK 5N102MPW-E-091挡片 D-UK 4/1013MPW-E-120隔离端子 E/NS 35N24MPW-E-109线槽1m5MPW-E-110导轨0.5m6MPW-E-072固定螺栓6紧固线槽、导轨注： 此两零件在 MPW-E-057就地掌握箱内部布置序号件号名称单台备注数量1MPW-E-069张力变送器12MPW-E-070张力变送器支架1序号件号名称单台数量备注1MPW-E-046本安操作箱12MPW-E-047急停按钮13MPW-E-048三位开关14MPW-E-049黑色功能开关15MPW-E-050工作指示灯16MPW-E-067黄色功能开关27MPW-E-128weiland 48 芯外罩1外部连接线用8MPW-E-062weiland 24 芯插座2未做出9MPW-E-262weiland 24 芯插针2外部连接线用10MPW-E-134weiland 24 芯外罩111MPW-E-12948 芯电缆4m内部连接用12MPW-E-126标牌7 块13MPW-E-06048 路开放底座114MPW-E-05224 路开放底座115MPW-E-056箱体紧固螺栓4 组16MPW-E-071尼龙电缆接头417MPW-E-112门锁118MPW-E-130导轨固定螺栓3固定导轨19MPW-E-131外罩固定螺栓8固定外罩20MPW-E-A-1连接电缆总成1连接就地箱和本安箱注：PLC 版 本安操作箱内部端子布置示意序号件号名称单台备注数量1MPW-E-088接线端子 UK5N242MPW-E-091端子挡片 D-UK 4/1023MPW-E-120隔离端子 E/NS 35 N34MPW-E-110导轨0.5m20序号件号名称单台数量备注1MPW-H-001油泵电机12MPW-H-002油箱13MPW-H-003呼吸器14MPW-H-004蓄能器15MPW-H-005电磁阀16MPW-H-006压力变送器17MPW-H-007液压阀块18MPW-H-008压力表1图中未作出9MPW-H-009压力油管3m10MPW-H-010油管转接接头211MPW-H-011内部油泵1MPW-H-ASM-001液压站组件1包括以上全部注：以下为 BREVINI 减速机备件21序号件号名称单台备注数量1MPW-G-001对接法兰12MPW-G-002轴承13MPW-G-003O 型圈14MPW-G-004O 型圈1序号件号名称单台数量备注1MPW-G-005内齿圈12MPW-G-006行星架13MPW-G-007太阳轮14MPW-G-008行星轮45MPW-G-009行星轮销轴46MPW-G-010隔离套47MPW-G-011轴承48MPW-G-012轴承19MPW-G-013卡圈810MPW-G-014卡圈411MPW-G-015端盖112MPW-G-016O 型圈113MPW-G-017O 型圈114MPW-G-018隔离套1序号件号名称单台数量备注1MPW-G-019外壳12MPW-G-020端盖13MPW-G-021轴承14MPW-G-022轴承15MPW-G-023油封26MPW-G-024磁性塞17MPW-G-025外壳紧固螺钉48MPW-G-026端盖紧固螺钉89MPW-G-027定位销110MPW-G-028O 型圈111MPW-G-029O 型圈112MPW-G-030卡圈1序号件号名称单台数量备注1MPW-G-031对接法兰12MPW-G-032轴承13MPW-G-033轴承14MPW-G-034定位销15MPW-G-035O 型圈16MPW-G-036O 型圈1序号件号名称单台数量备注序号件号名1MPW-G-037对接法兰115MPW-G-051卡圈2MPW-G-038法兰117MPW-G-053双头螺4MPW-G-040齿轮轴118MPW-G-054螺钉7MPW-G-043轴承119MPW-G-055螺母8MPW-G-044摩擦片120MPW-G-056螺母9MPW-G-045制动器外壳121MPW-G-057垫圈13MPW-G-049O 型圈122MPW-G-058垫圈14MPW-G-050O 型圈MPW-G-ASM-001制动器序号件号名称单台数量备注序号件号名1MPW-G-059外壳17MPW-G-065齿轮+齿2MPW-G-060法兰112MPW-G-066轴3MPW-G-061法兰113MPW-G-067垫片4MPW-G-062端盖114MPW-G-068垫片5MPW-G-063法兰115MPW-G-069垫片6MPW-G-064法兰116MPW-G-070轴承序号件号名称单台数量备注序号件号名17MPW-G-071轴承129MPW-G-082螺栓18MPW-G-072轴承130MPW-G-083螺钉19MPW-G-073轴承133MPW-G-084平垫20MPW-G-074O 型圈134MPW-G-085平垫21MPW-G-075O 型圈145MPW-G-086螺钉22MPW-G-076O 型圈146MPW-G-087平垫23MPW-G-077O 型圈147MPW-G-088盖25MPW-G-078键248MPW-G-089O 型圈26MPW-G-079锁紧螺母149MPW-G-090螺钉27MPW-G-080制动垫片163MPW-G-091螺钉28MPW-G-081油封1注： 以下为变频器备件参考资料29件号MPW-E-113名称备注变频器冷却风扇 01件号名称备注MPW-E-114变频器冷却风扇 02件号名称备注MPW-E-115电路板安装支架30件号MPW-E-116光纤电缆 01名称备注件号名称备注MPW-E-117光纤电缆 02件号MPW-E-118密封胶圈名称备注32件号MPW-E-120件号MPW-E-121名称备注水晶头插件名称备注风扇外罩件号名称备注MPW-E-125衬垫件号MPW-E-127名称备注晶体管模块单元39件号MPW-E-128名称备注铠装线缆件号名称备注MPW-E-129通道掌握二极管安装板件号MPW-E-130名称备注滤波板件号名称备注MPW-E-131钳位电容件号MPW-E-132名称备注滤波器件号名称备注MPW-E-133滤波器电路板件号名称备注MPW-E-135放电电阻件号名称备注MPW-E-138压敏电阻件号MPW-E-139名称备注充电电阻件号名称备注MPW-E-140操作面板件号MPW-E-142通讯模块名称备注