厕浴间防水工程-厕浴间聚氨酯涂膜防水工程质量技术交底卡1.doc

《厕浴间防水工程-厕浴间聚氨酯涂膜防水工程质量技术交底卡1.doc》由会员分享，可在线阅读，更多相关《厕浴间防水工程-厕浴间聚氨酯涂膜防水工程质量技术交底卡1.doc（111页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、【精品文档】如有侵权，请联系网站删除，仅供学习与交流厕浴间防水工程-厕浴间聚氨酯涂膜防水工程质量技术交底卡1.精品文档.厕浴间防水工程-厕浴间聚氨酯涂膜防水 分项工程质量技术交底卡GD2301003 施工单位海南省第四建筑工程公司工程名称翠屏富通雅苑分部工程建筑装饰装修工程交底部位首层十七层（A1幢）首层十五层（B1幢）日 期 年 月 日一、 施工准备（一） 作业条件1、 厕浴间楼地面垫层巳完成,穿过厕浴问地面及楼面的所有立管、套管已完成,并已固定牢固,经过验收。管周围缝隙用1:2:4豆石混凝土填塞密实(楼板底需吊模板)。2、 厕浴问楼地面找平层已完成,标高符合要求,表面应抹平压光、坚实、平整

2、,无空鼓、裂缝、起砂等缺陷,含水率不大于9%。3、 找平层的泛水坡度应在2%(即1:50),不得局部积水,与墙交接处及转角处、管根部位,均要抹成半径为100mm的均匀一致、平整光滑的小圆角,要用专用抹子。凡是靠墙的管根处均要抹出5%(1:20)坡度,避免此处积水。4、 涂刷防水层的基层表面,应将尘土、杂物清扫干净,表面残留的灰浆硬块及高出部分应刮平,扫净。对管根周围不易清扫的部位,应用毛刷将灰尘等清除,如有坑洼不平处或阴阳角未抹成圆弧处,可用众霸胶:水泥:砂=1:1.5:2.5砂浆修补。5、 基层做防水涂料之前,在突出地面和墙面的管根、地漏、排水口、阴阳角等易发生渗漏的部位,应做附加层增补。6

3、、 厕浴间墙面按设计要求及施工规定(四周至少上卷300mm)有防水的部位,墙面基层抹灰要压光,要求平整,无空鼓、裂缝、起砂等缺陷。穿过防水层的管道及固定卡具应提前安装并在距管50mm菏围内凹进表层5mm,管根做成半径为10mm的圆弧。7、 根据墙上的+0.5m水平控制线,弹出墙面防水高度线,标出立管与标准地面的交界线涂料涂刷时要与此线平。8、 厕浴间做防水之前必须设置足够的照明设备(安全低压灯等)和通风设备。9、 防水材料一般为易燃有毒物品,储存、保管和使用时要远离火源,施工现场要备有足够的灭火器等消防器材,施工人员要着工作服,穿软底鞋,并设专业工长监管。10、 环境温度保持在+5以上。11、

4、 操作人员应经过专业培训考核合格后,持证上岗,先做样板间,经检查验收合格,方可全面施工。（二） 材质要求单组分聚氨酪防水涂料(由于双组分、多组分聚氨酷防水涂料含有大量有机溶剂,对环境污染严重,己禁止此类材料使用于建筑物内部厕浴间等防水工程)。单组分聚氨酷防水涂料是以异氰酸酷、聚醚为主要原料,配以各种助剂制成,属于无有机溶剂挥发的单组分柔性防水涂料。其性能指标见下表。专业技术负责人：交底人：接受人：厕浴间防水工程-厕浴间聚氨酯涂膜防水 分项工程质量技术交底卡GD2301003 施工单位海南省第四建筑工程公司工程名称翠屏富通雅苑分部工程建筑装饰装修工程交底部位首层十七层（A1幢）首层十五层（B1幢

5、）日 期 年 月 日项目指标LH固体含量（）80拉伸强度Mpa1.92.45断裂伸长率（）350450不透水性0.3Mpa，30min不透水低温柔性 （）-40弯折无裂纹干燥时间表干时间（h）12实干时间（h）24注：L指低强度高延伸率型 H指高强度低延伸率型（一） 施工机具主要机具:电动搅拌器、搅拌桶、小漆桶、塑料刮板、铁皮小刮板、橡胶刮板、弹簧秤、毛刷、滚刷、小抹子、油工铲刀、笤帚、消防器材、风机等。二、 工艺流程基层清理细部附加层施工第一层涂膜第二层涂膜第三层涂膜第一次试水保护层施工第二次试水工程质量验收三、 操作工艺（一） 基层清理涂膜防水层施工前,先将基层表面上的灰皮用铲刀除掉,用笤

6、帚将尘土、砂粒等杂物清扫干净,尤其是管根、地漏和排水口等部位要仔细清理。如有油污时,应用钢丝刷和砂纸刷掉。基层表面必须平整,凹陷处要用水泥腻子补平。（二） 细部附加层施工1、 打开包装桶后先搅拌均匀。严禁用水或其他材料稀释产品。2、 细部附加层施工:用油漆刷蘸搅拌好的涂料在管根、地漏、阴阳角等容易漏水的薄弱部位均匀涂刷,不得漏涂(地面与墙角交接处,涂膜防水上卷墙上250mm高)。常温4h表干后,再刷第二道涂膜防水涂料,24h实干后,即可进行大面积涂膜防水层施工,每层附加层厚度宜为0.6mm。专业技术负责人：交底人：接受人：厕浴间防水工程-厕浴间聚氨酯涂膜防水 分项工程质量技术交底卡GD2301

7、003 施工单位海南省第四建筑工程公司工程名称翠屏富通雅苑分部工程建筑装饰装修工程交底部位首层十七层（A1幢）首层十五层（B1幢）日 期 年 月 日（三） 涂膜防水层施工聚氨酷防水涂膜一般厚度为l.lmm、1.5mm、2.0mm,根据设计厚度不同,可分成两遍或三遍进行涂膜施工。1、 打开包装桶先搅拌均匀。2、 第一层涂膜:将巳搅拌好的聚氨酯涂膜防水涂料用塑料或橡胶刮板均匀涂刮在巳涂好底胶的基层表面上,厚度为0.6mm,要均匀一致,刮涂量以0.60.8kg/m2为宜,操作时先墙面后地面,从内向外退着操作。3、 第二道涂膜:第一层涂膜固化到不粘手时,按第一遍材料施工方法,进行第二道涂膜防水施工。为

8、使涂膜厚度均匀,刮涂方向必须与第一遍刮涂方向垂直,刮涂量比第一遍略少,厚度为0.5mm为宜。4、 第三层涂膜:第二层涂膜固化后,按前述两遍的施工方法,进行第三遍刮涂,刮涂量以0.40.5kg/m2为宜(如设计厚度为1.5mm以上时,可进行第四次涂刷)。5、 撤粗砂结合层:为了保护防水层,地面的防水层可不撒石渣结合层,其结合层可用l:l的108胶或众霸胶水泥浆进行扫毛处理,地面防水保护层施工后,在墙面防水层滚涂一遍防水涂料,未固化时,在其表面上撒千净的23mm砂粒,以增加其与面层的粘结力。6、 保护层或饰面层施工。（四） 防水层细部施工1、 管根与墙角(见图4-7)专业技术负责人：交底人：接受人

9、：厕浴间防水工程-厕浴间聚氨酯涂膜防水 分项工程质量技术交底卡GD2301003 施工单位海南省第四建筑工程公司工程名称翠屏富通雅苑分部工程建筑装饰装修工程交底部位首层十七层（A1幢）首层十五层（B1幢）日 期 年 月 日2、 地漏处细部做法(见图4-8)3、 门口细部做法(见图4-9)（五） 涂膜防水层的验收根据防水涂膜施工工艺流程,按检验批、分项工程对每道工序进行认真检查验收,做好记录,须合格方可进行下道工序施工。防水层完成并实干后,对涂膜质量进行全面验收,要求满涂,厚度均匀一致,封闭严密,厚度达到设计要求(做切片检查)。防水层无起鼓、开裂、翘边等缺陷,并且表面光滑。经检查验收合格后可进行

10、蓄水试验(蓄水深度高出标准地面20mm),24h无渗漏,做好记录,可进行保护层施工。专业技术负责人：交底人：接受人：厕浴间防水工程-厕浴间聚氨酯涂膜防水 分项工程质量技术交底卡GD2301003 施工单位海南省第四建筑工程公司工程名称翠屏富通雅苑分部工程建筑装饰装修工程交底部位首层十七层（A1幢）首层十五层（B1幢）日 期 年 月 日四、 成品保护1、 涂膜防水层操作过程中,操作人员要穿平底鞋作业,穿过地面及墙面等处的管件和套管、地漏、固定卡子等,不得碰损、变位。涂防水涂膜施工时,不得污染其他部位的墙地面、门窗、电气线盒、暖卫管道、卫生器具等。2、 涂膜防水层每层施工后,要严格加以保护,在厨卫

11、间门日要设醒目的禁入标志,在保护层施工之前,任何人不得进入,也不得在上面堆放杂物,以免损坏防水层。3、 地漏或排水口在防水施工之前,应采取保护措施,以防杂物进人,确保排水畅通,蓄水合格,将地漏内清理干净。4、 防水保护层施工时,不得在防水层上拌砂浆,铺砂浆时铁锹不得触及防水层,要精工细做,不得损坏防水层。五、 应注意的质量问题1、 涂膜防水层空鼓、有气泡:主要是基层清理不干净,涂刷不匀或者找平层潮湿,含水率高于9%;涂刷之前未进行含水率检验,造成空鼓,严重者造成大面积鼓包。因此在涂刷防水层之前,必须将基层清理干净,并保证含水率合适。2、 地面面层施工后,进行蓄水试验,有渗漏现象:主要原因是穿过

12、地面和墙面的管件、地漏等松动,烟风道下沉,撕裂防水层;其他部位由于管根松动或粘结不牢、接触面清理不干净产生空隙,接搓、封日处搭接长度不够,粘贴不紧密;做防水保护层时可能损坏防水层;第一次蓄水试验蓄水深度不够。因此要求在施工过程中,对相关工序应认真操作，加强责任心,严格按工艺标准和施工规范进行操作。涂膜防水层施工后,进行第一次蓄水试验,蓄水深度必须高于标准地面20mm,24h不渗漏为止,如有渗漏现象,可根据渗漏具体部位进行修补,甚至于全部返工。地面面层施工后,再进行第二遍蓄水试验,24h无渗漏为最终合格,填写蓄水检查记录。3、 地面排水不畅:主要原因是地面面层及找平层施工时未按设计要求找坡,造成

13、倒坡或凹凸不平而存水。因此在涂膜防水层施工之前,先检查基层坡度是否符合要求,与设计不符时,应进行处理再做防水,面层施工时也要按设计要求找坡。4、 地面二次蓄水试验后,已验收合格,但在竣工使用后仍发现渗漏现象;主要原因是卫生器具排水口与管道承插口处未连接严密,连接后未用建筑密封膏封密实,或者是后安卫生器具的固定螺丝穿透防水层而未进行处理。在卫生器具安装后,必须仔细检查各接口处是否符合要求,再进行下道工序。要求卫生器具安装后,注意成品保护。专业技术负责人：交底人：接受人：（英文版 ） easily blame, to prevent the broken window effect. Superv

14、ise the leading cadres to play an exemplary role, take the lead in the strict implementation of the and , lead to safeguard the solemnity and authority of the party discipline, ensure that the party discipline and the laws and regulations for implementation in place. Throughout the discipline in the

15、 daily supervision and management, strengthen supervision and inspection, from the thorough investigation of violations of discipline behavior. Strengthen to key areas, key departments and key projects as well as the masses reflect the concentration of the units and departments for supervision. - st

16、rengthening supervision, discipline inspection and supervision of cadres to set an example for compliance with the and is a man must be hexyl, blacksmith needs its own hardware. Discipline inspection organs as the executor of the party discipline, and supervisor of the defenders, for its supervision

17、 must be more strictly, discipline inspection and supervision of cadres to firmly establish the awareness of Party Constitution, sense of discipline and rules consciousness, politics loyalty, sense obey. Action speak Ji Ordinance to set an example of the regulations of the rule of law, strengthen su

18、pervision and accept the supervision of the firmness and consciousness, do comply with and . To firmly establish the discipline must first be disciplined, the supervisor will be subject to the supervision of concept, and consciously safeguard and implement party compasses party, take the lead in pra

19、cticing three strict real strict, so loyal, clean, play. To be good at learning, the Constitution and the as morality, politics and brought to fruition; to implement , do not want to, dare not, not with disciplinary ruler to supervision; to discipline a ruler, often the control inspection, and consc

20、iously in the ideological red line to draw the row Ming Good accumulation is indeed the bottom line, so that the heart has fear, said to have quit, the line has ended. Attached: indifferent to heart, calmly to the table in our life, there are many unpredictable things will happen, some good, some ba

21、d things, we cannot control is powerless to stop, but with time, you will find in life sometimes turns out to be not good, some bad things finally turned out to be a good thing, but then we muddy however did not know, this is the life teach us things. 1, life can be complex, can also be simple. Want

22、 simple life of precipitation, to have enough time to reflect, to make Become more perfect. Life is the most important thing is not to win, but the struggle; not to have conquered, but to have fought well. 2, the plain is the background of life. Live a plain life, give up on themselves is not a cowa

23、rd, but the wise answers; not disillusioned after the heart, such as ashes, but experience the storm after the enlightenment; not unrewarding perfunctorily, but calm attitude of life of unrestrained self-confidence. Plain living, there is no noise noisy, no earthly troubles, more did not fill in the

24、 discontent of desire, some just a calm, a calm. 3, memory of heart will not good things to erase the, life is a When no movie, pain is a beginning, the struggle is a kind of process, death is a kind of ending. Give up this giving up is the helpless, do not give up the abandoned, do not give up this

25、 giving up is ignorance, do not give up should not give up is persistent. 4, a thing figured is heaven, think impassability is hell. Since the living, to live better. Sometimes we because of too narrow-minded, too care around the chores and penny wise and pound foolish, not worth the candle. Some th

26、ings to attract trouble and worry, completely depends on how we look at and deal with it. Dont always take everything back to things, and dont get into a blind alley, dont want to face, dont be narrow-minded. Poke to care, is a kind of open-minded, a free and easy. 5, I am not afraid of others behin

27、d me a knife, I afraid to look back and see stab me, is my intention to treat people; I am not afraid of the truth to tell the best friend, Im afraid he turned to it as a joke to tell dont 6, when we are in a positive frame of mind, you will find many good things; and when we are in a negative state

28、 of mind, you will find many depressed things; life happy and worry, all is you of life attitude, optimistic, good luck; loss of sink, Eritrea company. When you are in adversity, may wish to change a point of view to think everything over to the good Think, because good mentality decided the fate of

29、 the! 7, people are tired, rest; heart tired, calm. Grow up, mature, this society read. Tired and sad, squat down, to their a hug. Because the world no one can sympathize with you, have mercy on you. You cry, tears is your own; you pain, no one can understand. Then you only tears to smile. 8, each p

30、eople have youth,Each youth are a story, the life of the world never gets easier, I want what, wish the world all know, as has been the same; now want anything, for fear that others know, or like to lose the same. 9, the heart move, everything in the world is followed by birth, Rangrang, important t

31、hing is often the most difficult to open ones mouth, because words will reduce its importance; to let strangers people care about your life in the good things, the original is not easy 10, do not blame, do not laugh at who, also dont envy who. Like a person is a kind of feeling, not like a person is

32、 true. The truth is easy to explain, I feel Is unspeakable. The best travel life is that you in a strange place found a long lost touched. 11, happy life not in the bustling in, and in the peace of mind; no matter how many grievances, how uncomfortable, and ultimately to heal themselves or their own

33、, others may got you to comfort, but never know your heart is how wanjianchuanxin. 12, maam, like a movie, learn to appreciate, learn to be grateful, learn tolerance, and goodness, helping others. Instead of accusing the society, as into one; and an exception is better to give than to what 13, dont

34、envy him A sum of, dont lose your life and the life, respectively is: the former is a we experienced cannot escape in a day finally will last minute, while the latter is our persistent, we want to cherish the memory of those people and things. 14, learn to smile, learn to strong, the world you know

35、so many people, so many people and you are, you cannot change also cant let everyone like you, so also do not want to do. Life is too short to go crazy to love to go to waste, to chase the dream to regret. 15, when temper, a blessing to go. A wounding elegant people, the key is to control their own

36、emotions. With the mouth is the most stupid behavior. A control negative emotions than a can take a city more powerful water flow slow, language is expensive. People spent two years of time to learn to speak, but to spend a few years time to shut up. That is a kind of ability, that is a kind of wisd

37、om. 16, life is not perfect, sometimes, growth is not a cry, not an eyeful of tears, there is no trace of emotion, there is no gleam of hope, no desire, no action, no static, there is only one kind of downward sinking feeling, sink A murky? 6? 7? 6? 7 sink? 6? 7? 6? 7 toward the bottom of the sink.

38、17, in some way, do not go, you will not know the other side scenery is beautiful. To you is not good, you do not mind too much, no one has an obligation to you; you learn knowledge, is you have weapons, you can start from scratch, but not unarmed; how do you treat people, does not represent how oth

39、ers treat you, if cannot see through this point, only inviting worry. 18, time is like a sponge in the water, as long as you are willing to squeeze, the total water is still there. Every life, after the ups and downs The best test of live, to life, survival and continuation, do not stop the struggle

40、 in the joys and sorrows of life on the road, so that different soul to bear life beat, acceptance of suffering. 19, indifferent to heart, calmly in table, elegant and comfortable life, do not take what is so important. The pursuit will be disappointed; to be alive, you will have trouble. Life is th

41、e most afraid of what all want to care about, but also what all grasp is not firm, without scenery, separated populations, such as not to desire, all docked in the fate of the end. Why is too rigid, the natural, to go stay not to live, let go of obsession, revel is 20, if the fate of the broken Hope

42、s of sailing, please dont despair, the coast is still, if the fate of the withered petals of the beautiful, please do not sink, the spring is still, life will always be endless trouble, please dont helpless, because they are still alive, is still a dream, the sun still, we still. Lost, keep memories

43、; to get, must work to; but the most important is good to cherish their own. 21, life, select the complex, is to choose the pain; choose a simple, is choose to be happy. The complex world like aSignificance of pride. Hope is the ornate palace, outside people admiring the magnificent, living in the d

44、eep knowledge of living it to pay the price. Simple world as a simple log cabin outside ridiculed shabby, the heart is willing to go live to know the joy. Suffering and joy is their own choice. 22, learn how to use a single powerful heart, let the past be the past, let the future come. Life is reall

45、y the end of the end of an eagle is flying wings, life is constantly pursuit. Dont miss to regret, dont wait for old just miss. Time to return, seize every moment, again painstakingly again tired also Those struggling to fly. 23, life could not Yimapingchuan, even flat pavement, inevitably there wil

46、l be a few pieces of roadblocks. Some of the rocks around the past, while others have to move it out. Just move others put the stone is very easy, because the stone from the appearance we can discern; difficult to myself to move away the heart of stone head. Leave time to spend with her, often refle

47、ct my heart, so as to remove your heart of stone. 24, everything does not have to be demanding, come to, everything does not have to care about, over the past; failing to do not frown, laugh it laugh. Results Dont demand, do to; life is a simple, calm and peaceful. Always not to choose their own path and regret, life is like a train, the scenery and then the United States will retreat, the passage of time and encounter will eventually drifting further and further away, before is always himself. 25, everyone has a weakness, weak