室内脚手架施工方案.doc

《室内脚手架施工方案.doc》由会员分享，可在线阅读，更多相关《室内脚手架施工方案.doc（59页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、【精品文档】如有侵权，请联系网站删除，仅供学习与交流室内脚手架施工方案.精品文档.哈医大二院综合楼脚手架施工方案编制：审核：批准：施工单位：黑龙江省美图建筑装饰工程有限公司目 录1、 工程概况2、 材料要求3、 施工方法4、 满堂红钢管脚手架与建筑物结构的连接5、 满堂红钢管脚手架的安全检查措施6、 满堂红钢管脚手架的拆除7、 安全防护措施8、 文明施工一、 工程概况1、 工程名称： 哈尔滨医科大学附属第二医院新建综合楼1-4层装修工程2、 工程特点本工程为哈尔滨医科大学附属第二医院综合楼1-4层装饰装修工程，位于哈尔滨市道里区学府路249号，学府路东侧，哈医大二院院内南侧，与高干病房楼相对而

2、立，结构为框架结构，我方施工建筑面积为97840.16平方米，多功能大厅为1-4层通体，室内地面标高距4层棚顶底标高相距17米，需搭设满堂脚手架进行施工，结合现场实际制定本方案，本工程建设单位为医大二院，监理单位为旭正建设工程监理有限公司，施工单位为黑龙江美图建筑装饰工程有限公司，承包方式为包工包料，工程范围1-4层通体大厅及电梯前室，具体工程量见图纸内容3、编制依据混凝土结构工程施工质量验收规范GB50204-2002建筑工程施工质量验收统一标准GB50300-2001建筑施工扣件式钢管脚手架安全技术规范JGJ 130-2001 建筑施工安全检查标准JGJ59-99-4、本工程室内装修搭设脚

3、手架的总体方案为采用立杆的横纵间距为1.2m，步距1.5m，操作层及坡道铺满钢质跳板，四周挂满密目安全网二、材料要求：1. 钢管：采用外径48mm,壁厚3.5mm的高频焊接钢管。材料要符合普通碳素结构钢技术条件GB700-79中的A3钢管技术条件。管材符合直径5152mm电焊钢管YB242-63中的甲类软钢管,低压流体输送用焊接钢管GB3092-82中的普通钢管的规定。有严重锈蚀、弯曲、 压偏、损伤和裂纹者均应剔除。钢管的长度应是脚手架步高的倍数,其重量要求方便操作杆件最大重量以不超过25kg为宜。按钢管在脚手架上所处的部位和所起的作用分为:(1) 立柱,立杆和竖杆等,是脚手架主要传递荷载的杆

4、件。(2) 大横杆,又称牵杆,纵向水平杆等。是保持脚手架纵向稳定的主要杆件。(3) 小横杆,又称横向水平杆,横担等。是脚手架直接承受荷载的杆件.(4) 横杆是脚手架的安全防护设施,又起着脚手架的纵向稳定作用。(5) 剪力撑,又称十字撑,科撑,是防止脚手架产生纵向位移的主要杆件。(6) 抛撑,用于脚手架外侧与地面呈斜角的斜撑,一般在开始搭设脚手架时固定之用。2. 扣件:扣件式钢管脚手架,所用的扣件,应符合JGJ22-85钢管脚手架扣件的规定,材质应符合GB78-67可锻铸铁分类及技术条件中KT33-8的技术条件。(1) 直角扣件,用于两根垂直交叉钢管的连接。(2) 旋转扣件,用于两根任意交叉钢管

5、的连接。(3) 对接扣件,用于两根钢管对接连接。3 底座: 用于承受脚手架立杆传递下来的荷载。(4) 铸铁底座,应符合JGJ22-85钢管脚手架扣件中的规定。(5) 焊接底座。4 连接杆：又称固定件,附墙杆、连接点、拉结点、拉撑点、附墙点等。 五、 满堂红脚手架方案验算：参数：立杆纵矩la = 1.2m 立杆横矩lb1.2m横杆步矩h = 1.5m扣件抗滑承载力R8.0KN脚手板自重：0.35KN/m2每米钢管重：0.038 KN/m施工均布荷载：2.0 KN/m21、横向水平杆验算：q 1.2（q1 q2）1.2Q1.2（35038.4）1.22000=2.866N/mmMmax=0.1ql

6、2 =0.12.86614002 =561736 NM= Mmax/W=561736/5080110.58N/2f205 N/2强度验算安全依据v=1400/150=9.333又根据：v10，取v=9.333vmax=0.677ql4/100EI =0.6772.86614004/1002.0610512.19104 =3.383vmaxv挠度验算安全 2、纵向水平杆验算P1=(1.2350+1.22000)0.71.2=2368.8NP2=1.2(1.238.4+13.2)=71.136 NP = P1+ P2=3155.6+71.136=3226.7NMmax=0.175Pl =0.175

7、3226.71400 =79054.2 NM= Mmax/W=79054.2/5080155.6N/2f205 N/2强度验算安全根据v1400/1509.333又根据v10，取v=9.333vmax=0.677ql4/100EI =0.6773.23614004/1002.0610512.19104 =3.352vmaxv挠度验算安全 3、扣件抗滑承载力验算N（1.2 q11.2Q）lalb+1.2(2 la + lb)38.4+213.2（1.23501.22000）1.21.21.2（21.21.2）38.4213.24258.34.2583KNNRc=8.0KN扣件抗滑承载力安全4、立

8、杆稳定性验算立杆所承受的轴向力N1.2（NG1kNG2k）1.4NQNG1kH（lalb）38.42n13.2（H/6.51）18.42（H/4.11）14.623.818（1.41.4）38.421813.2（23.8/6.51）18.42（23.8/4.1+1）14.6 =3576.57NNG2k=H/1235023.8/121.41.43501360.57NNQk= la lb20001.41.420003920 NN1.2（3576.571360.57）1.4392011414.57 N立杆稳定性验算立杆计算长度系数查表得：u1.52立杆计算长度lo= uh1.521.52.28m长细

9、比：lo/2280/15.8144由144查表得：稳定性系数：0.308根据公式：1.2N/Af进行验算1.2N/A1.211414.57/0.30848990.95 N/2f205 N/2立杆稳定性安全5、立杆地基承载力：由于立杆立在室内钢筋砼地面上所以不需要验算，室内地面符合承载要求六、施工方法1 落地搭设：根据本工程的具体情况和场地条件,采用落地式搭设满堂红脚手架。搭设脚手架前,应按照本工程的设计图纸要求及满足施工需要进行布置搭设。2 脚手架的基础： 落地搭设的施工用脚手架,脚手架的自重及其上部的施工荷载均由脚手架基础传至地基。故此要使脚手架保持稳定,牢固和安全,必须首先要有一个牢固的脚

10、手架基础，因本工程在室内施工，室内砼地面符合承重要求，搭接前需平整场地，填补坑洞，和室内标高一致达到平整要求。3 扣件式钢管脚手架的搭设 施工用的满堂红钢管脚手架搭设的要求是:横平竖直,整齐清晰,图形一致，平竖通顺,连接牢固,受荷安全,有安全操作空间,不变形,不摇晃。4 满堂红钢管脚手架搭设的施工顺序:安立杆安扫地杆按横杆铺钢质跳板安上层立杆安上层横杆逐层只设到室内4层楼底板，首先在底部距地面100mm处设置一道扫地杆,以保持脚手架底部的整体性,底部的立柱应间隔交叉用不同长度的钢管,将相隔立柱的对接接头位于不同高度上,使立柱受荷的薄弱截面错开,满堂红脚手架搭设时先立立柱, 立柱与扫地杆采用直角

11、扣件固定牢固，架设时考虑到室内大厅的跨度而设置成长方形环绕室内四周。立柱每条隔距按照尺寸,立好柱后,架设大,小横杆,当第一步的大小横杆架设完毕后,做好固定件,以方便操作者上去架设第二步脚手架;同时在立柱之间的规定位置及时设置剪力撑,以防止脚手架纵向倾倒,剪力撑的搭设必须与架体的向上搭设同步进行。立柱接杆、接长应用对接扣件,不能采用旋转扣件;横杆与立柱连接采用直角扣件,剪力撑和斜撑与立杆和大横杆的连接应采用旋转扣件,剪力撑的纵向接长应采用旋转扣件,不能采用对接扣件,所有的扣件紧固要求用力矩板手实测达到4070N.m,在安装扣件时,所有的扣件的开口必须向外。(1) 在搭设满堂红脚手架时;每完成一步

12、都要及时校正立柱的垂直度和横杆的标高和水平度,使脚手架的横距,纵距上下始终保持一致。(2) 满堂红脚手架搭设完毕应进行验收,验收合格并办妥验收手续方可使用.七、满堂红钢管脚手架的安全检查措施每日进行一次，定期的维护保养，一般每月进行一次，1 检查脚手架的基础有无局部不均匀下沉，脚手架底部有无堆放杂物。2 检查脚手架的整体和局部的垂直偏差，特别要注意脚手架的转角处的垂直度，如发现垂直度有异常现象，应及时加固和消除隐患。3 各类扣件的涂油和紧固检查扣件时先检查扣件的外观，而后将扣件的螺栓逆时针方向松几牙螺纹，再涂油紧固螺栓至规定的力距范围。4 与建筑物连接的检查；检查连接件是否齐全完好，有无松动、

13、移动。八、满堂红钢管脚手架的拆除满堂红钢管脚手架在拆除前必须做好以下工作：1 对脚手架进行安全检查，确认脚手架不存在严重隐患如存在影响拆除脚手架安全隐患，应先对脚手架，进行整修和加固，以保证脚手架在拆除过程不发生危险。2 对参与脚手架，拆除的操作人员、管理人员和检查、监护人员进行安全、保护等措施的交底，交底的的内容应包括拆除范围，数量、时间和拆除顺序，方法。拆除的安全措施和警戒区域。交底要有记录，双方均应在交底书上签字。4 在拆除的脚手架周围,于坠落范围四周设置明显“禁止入内”的标志,并有专人监护，以保证在拆脚手架时无其它人员入内。上述这些工作经检查符合要求后,并确认建筑施工再也不需要用脚手架

14、时,就可进行脚手架拆除。脚手架的拆除应从上往下,水平方向一步拆完再拆下一步随着脚手架的向下拆除,对墙面的饰面,窗及其它墙面装饰及时做好清洁和保护工作,对脚手架的连接处饰面的补修应与脚手架的拆除同步进行,饰面补修经检查认定合格,做好清洁和保护工作后方可继续向下拆除脚手架。拆除脚手架应一步步进行,由上而下,一步一清地进行拆除。拆下的脚手架钢管,扣件及其它材料运到地面后,应及时清理,将合格的,需要整修后可重复使用的和应报废的加以区分,按规格堆放。对合格件应及时进行保养,保养后送仓库保管,以备今后使用。拆除脚手架时要遵守GB3608-83高处作业的有关规定,特别是按关于强风区高处作业,雨天高处作业和雷

15、天高处作业的有关规定执行。每日拆除脚手架告一段落时，都要对尚未拆除的脚物架的安全状况进行检查,还要对周围环境进行检查,如有异常情况应及时处理,确认一切均安全后方可离岗,不可疏忽大意,留有隐患。九、安全防护措施安全施工在施工方案中多处提及,对于脚手架有牢固的骨架,可靠的连接。稳妥的基底,并按正确的顺序搭设和拆除,这些均是保证安全的重要环节,除此之外,尚需重视在使用过程中出现的安全防护问题,并在各出入口及通道挂上安全标志。1 在施工期间应派专人定期和不定期检查脚手架的安全情况,做到无事故隐患,发现隐患及时处理。4 在搭建作业时应做好安全防护,作业人员必须戴安全帽,系安全带及穿胶底鞋。十一、文明施工

16、1 施工现场按平面图堆放材料，材料要堆放整齐。2 施工现场要经常保持整洁卫生，搭设后应当把余下的材料堆放整齐，杂物清理运走。4 在施工完成后要检查场地的杂乱情况，如有不符合安全、文明施工要求的要马上整改。（英文版 ） Two regulations promulgated for implementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementa

17、tion in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulations supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high

18、 standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party organizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduce

19、s two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principles of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several k

20、ey problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised history of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2

21、015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party, ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow

22、 the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the problem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the exper

23、ience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensive strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen

24、 the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering the deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also

25、 difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requirements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regu

26、lations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level leading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very

27、 important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is

28、 the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party Constitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party m

29、embers. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put the authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party co

30、mpasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for D

31、iscipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Discipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection

32、4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, major issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of

33、the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsible for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of

34、 China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous regions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department o

35、f the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of extensive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau St

36、anding Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, the Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, e

37、mbodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revis

38、ed and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about

39、discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the authority of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must foll

40、ow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 16th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of

41、the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution

42、about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party and the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to th

43、e self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative li

44、st, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and ca

45、dres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main problems of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against the four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, p