混凝土泵车安全技术交底 ..doc

《混凝土泵车安全技术交底 ..doc》由会员分享，可在线阅读，更多相关《混凝土泵车安全技术交底 ..doc（54页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、【精品文档】如有侵权，请联系网站删除，仅供学习与交流混凝土泵车安全技术交底 .精品文档.安全技术交底记录工程名称：昆明市域公交快线工程（广电大学站） 编号：. 施工单位中铁十六局集团有限公司交底时间交底部位工序名称交底提要：混凝土泵车安全技术交底交底内容：1构成混凝土泵车的汽车底盘、内燃机、空气压缩机、水泵、液压装置等的使用，应分别按照水平运输机械、动力装置、水工机械安全交底要求操作。2泵车就位地点应平坦坚实，周围无障碍物，上空无高压输电线。泵车不得停放在斜坡上。3泵车就位后，应支起支腿并保持机身的水平和稳定。当用布料杆送料时，机身倾斜度不得大于3。4就位后，泵车应显示停车灯，避免碰撞。5作业

2、前检查项目应符合下列要求：(1)燃油、润滑油、液压油、水箱添加充足，轮胎气压符合规定，照明和信号指示灯齐全良好；(2)液压系统工作正常，管道无泄漏；清洗水泵及设备齐全良好；(3)搅拌斗内无杂物，料斗上保护格网完好并盖严；(4)输送管路连接牢固，密封良好。6布料杆所用配管和软管应按出厂说明书的规定选用，不得使用超过规定直径的配管，装接的软管应拴上防脱安全带。7伸展布料杆应按出厂说明书的顺序进行。布料杆升离支架后方可回转。严禁用布料杆起吊或拖拉物件。8当布料杆处于全伸状态时，不得移动车身。作业中需要移动车身时，应将上段布料杆折叠固定，移动速度不得超过l0kmh。9不得在地面上拖拉布料杆前端软管；严

3、禁延长布料配管和布料杆。当风力在六级及以上时，不得使用布料杆输送混凝土。10泵送管道的敷设，应符合下列要求：(1)水平泵送管道宜直线埋设。(2)垂直泵送管道不得直接装接在泵的输出口上，应在垂直管前端加装长度不小于20m的水平管，并在水平管近泵处加装逆止阀。(3)敷设向下倾斜的管道时，应在输出口上加装一段水平管，其长度不应小于倾斜管高低差的5倍。当倾斜度较大时，应在坡度上端装设排气活阀。(4)泵送管道应有支承固定，在管道和固定物之间应设置木垫作缓冲，不得直接与钢筋或模板相连，管道与管道间应连接牢靠；管道接头和卡箍应扣牢密封，不得漏浆；不得将已磨损管道装在后端高压区。 (5)泵送管道敷设后，应进行

4、耐压试验。11泵送前，当液压油温度低于15C时，应采用延长空运转时间的方法提高油温。12泵送时应检查泵和搅拌装置的运转情况，监视各仪表和指示灯，发现异常，应及时停机处理。13料斗中混凝土面应保持在搅拌轴中心线以上。14泵送混凝土应连续作业。当因供料中断被迫暂停时，停机时间不得超过30min。暂停时间内应每隔5l0min(冬季35min)作23个冲程反泵一正泵运动，再次投料泵送前应先将料搅拌。当停泵时间超限时，应排空管道。15作业中，不得取下料斗上的格网，并应及时清除不合格的骨料或杂物。16泵送中当发现压力表上升到最高值，运转声音发生变化时，应立即停止泵送，并应采用反向运转方法排除管道堵塞；无效

5、时，应拆管清洗。17作业后，应将管道和料斗内的混凝土全部输出，然后对料斗、管道等进行冲洗。当采用压缩空气冲洗管道时，管道出口端前方10m内严禁站人。18作业后，不得用压缩空气冲洗布料杆配管，布料杆的折叠收缩应按规定顺序进行。19作业后，各部位操纵开关、调整手柄、手轮、控制杆、旋塞等均应复位，液压系统应卸荷，并应收回支腿，将车停放在安全地带，关闭门窗。冬季应放净存水。技术负责人交底人接受交底人注：1、本表用于施工单位对作业班组的安全技术交底；2、本表一式三份，交底后施工单位项目部、作业班组各留一份，报监理机构一份备案（英文版 ） Two regulations promulgated for i

6、mplementation is in the party in power for a long time and the rule of law conditions, the implementation of comprehensive strictly strategic plan, implementation in accordance with the rules and discipline to manage the party, strengthen inner-party supervision of major initiatives. The two regulat

7、ions supporting each other, the adhere to a positive advocate, focusing on morality is of Party members and Party leading cadres can see, enough to get a high standard; around the party discipline, disciplinary ruler requirements, listed as negative list, focusing on vertical gauge, draw the party o

8、rganizations and Party members do not touch the bottom line . Here, the main from four square face two party rules of interpretation: the first part introduces two party Revised regulations the necessity and the revision process; the second part is the interpretation of the two fundamental principle

9、s of the revision of laws and regulations in the party; the third part introduces two party regulations modified the main changes and needs to grasp several key problems; the fourth part on how to grasp the implementation of the two regulations of the party. and revised the necessity and revised his

10、tory of the CPC Central Committee the amendment to the Chinese Communist Party members and leading cadres honest politics several guidelines and column 1 by 2015 to strengthen party laws and regulations focus. Two party regulations revision work lasted a Years, pooling the wisdom of the whole party,

11、 ideological consensus, draw historical experience, respect for the wisdom of our predecessors, which reflects the unity of inheritance and innovation; follow the correct direction, grasp the limited goals, adhere to the partys leadership, to solve the masses of the people reflect a focus on the pro

12、blem. The new revision of the and , reflects the partys 18 and the eighth session of the third, the spirit of the fourth plenary session, reflecting the experience of studying and implementing the General Secretary Xi Jinping series of important speech, reflects the partys eighteen years comprehensi

13、ve strictly practice. (a) revised two regulations of the party need of in based on revised, the promulgation and implementation of January 2010, to strengthen the construction of the contingent of leading cadres play an important role. But with the party to manage the party strictly administering th

14、e deepening, has not been able to fully meet the actual needs. Content is too complicated, eight prohibition, 52 are not allowed to hard to remember, and also difficult to put into practice; the second is concisely positive advocated by the lack of prohibited provisions excessive, no autonomy requir

15、ements; the third is banned terms and discipline law, both with the party discipline, disciplinary regulations repeat and Criminal law and other laws and regulations repeat; the fourth is to clean the theme is not prominent, not for the existing problems, and is narrow, only needle of county-level l

16、eading cadres above. is in 1997 based on revision, in December 2003 the promulgation and implementation, to strengthen the construction of the party play very important role. Along with the development of the situation, which many provisions have been unable to fully meet the comprehensive strictly

17、administering the practice needs. One is Ji law, more than half of the provisions and criminal law and other countries laws and regulations Repetition; two is the political discipline regulations is not prominent, not specific, for violation of the party constitution, damage the authority of Party C

18、onstitution of misconduct lack necessary and serious responsibility to pursue; third is the main discipline for the leading cadres, does not cover all Party members. Based on the above situation, need to and the two is likely to be more relevant regulations first amendment. By revising, really put t

19、he authority of Party discipline, the seriousness in the party tree and call up the majority of Party members and cadres of the party constitution of party compasses party consciousness. (II) two party regulations revision process the Central Committee of the Communist Party of China attaches great

20、importance to two regulations revision . Xi Jinping, general books recorded in the Fifth Plenary Session of the eighth session of the Central Commission for Discipline Inspection, on the revised regulations made clear instructions. According to the central deployment, the Central Commission for Disc

21、ipline Inspection from 2014 under six months begin study two regulations revision. The Standing Committee of the Central Commission for Discipline Inspection 4 review revised. Comrade Wang Qishan 14 times held a special meeting to study two regulations revision, amendment clarifies the direction, ma

22、jor issues of principle, path and target, respectively held a forum will listen to part of the province (area) secretary of the Party committee, Secretary of the Discipline Inspection Commission, part of the central ministries and state organs Department The first party committee is mainly responsib

23、le for people, views of experts and scholars and grassroots party organizations and Party members. Approved by the Central Committee of the Communist Party of China, on 7 September 2015, the general office of the Central Committee of the Party issued a notice to solicit the provinces (autonomous reg

24、ions, municipalities) Party, the central ministries and commissions, state ministries and commissions of the Party (party), the General Political Department of the military, every 3 people organization of Party of two regulations revision opinion. Central Commission for Discipline Inspection of exte

25、nsive solicitation of opinions, careful study, attracting, formed a revised sent reviewers. In October 8 and October 12, Central Committee Political Bureau Standing Committee and the Political Bureau of the Central Committee After consideration of the two regulations revised draft. On October 18, th

26、e Central Committee of the Communist Party of China formally issued two regulations. Can say, two laws amendment concentrated the wisdom of the whole party, embodies the party. Second, and revision of the basic principles of two party regulations revision work and implement the partys eighteen, ten

27、eight plenary, the spirit of the Fourth Plenary Session of the Eleventh Central Committee and General Secretary Xi Jinping important instructions on the revised and , highlighting the ruling party characteristics, serious discipline, the discipline quite in front of the law, based on the current, a

28、long-term, advance as a whole, with Bu Xiuding independent and . Main principle is: first, adhere to the party constitution to follow. The constitution about discipline and self-discipline required specific, awaken the party constitution of party compasses party consciousness, maintaining the author

29、ity of the constitution. General Secretary Xi Jinping pointed out that no rules, no side round. Party constitution is the fundamental law, the party must follow the general rules. In early 2015 held the eighth session of the Central Commission for Discipline Inspection Fifth Plenary Session of the 1

30、6th Central Committee, Xi Jinping again pointed out that constitution is the party must follow the general rules, but also the general rules. the revision of the and is Method in adhere to the regulations established for the purpose of combining rule of virtue is to adhere to the party constitution

31、as a fundamental to follow, the constitution authority set up, wake up the party constitution and party rules the sense of discipline, the party constitution about discipline and self-discipline specific requirements. 4 second is to adhere to in accordance with the regulations governing the party an

32、d the party. The Party of rule of virtue de, mainly refers to the partys ideals and beliefs, excellent traditional style. The revised the closely linked to the self-discipline, insisting on the positive initiative, for all members, highlight the vital few, emphasized self-discipline, focusing on the

33、 morality, and the majority of Party members and the ideological and moral standards. The revised Ji method separately, Ji, Ji Yan to Method, as a negative list, emphasizing the heteronomy, focusing on vertical gauge. Is this one high and one low, a positive reaction, the strict party discipline and

34、 practice results transformation for the integration of the whole party to observe moral and discipline requirements, for the majority of Party members and cadres provides benchmarking and ruler. Third, insist on to. In view of the problems existing in the party at the present stage, the main proble

35、ms of Party members and cadres in the aspect of self-discipline and abide by the discipline to make clearly defined, especially the partys eighteen years strict political discipline and political rules, organization and discipline and to implement the central eight provisions of the spirit against t

36、he four winds and other requirements into Disciplinary provisions. Not one pace reachs the designated position, focusing on in line with reality, pragmatic and effective. After the revision of major changes, major changes in the and modified and needs to grasp several key problems (a) adhere to acco

37、rding to regulations governing the party and party with morals in combination, for at the present stage, the leadership of the party members and cadres and Party members in existing main problems of self-discipline, put forward principles, requirements and specifications, showing Communists noble mo

38、ral pursuit, reflected at all times and in all over the world ethics from high from low 5 common requirements. One is closely linked to the self-discipline, removal and no direct relation to the provisions of . the second is adhere to a positive advocate, eight prohibition 52 are not allowed to abou

39、t the content of the negative list moved into synchronization amendment . Three is for all the party members, will apply object from the leadership of the party members and cadres to expand to all Party members, fully embodies the comprehensive strictly required. The fourth is prominent key minority

40、, seize the leadership of the party members and cadres is the key, and put forward higher requirements than the ordinary Party members. Five is to simplify, and strive to achieve concise, easy to understand, easy to remember. The revised is the ruling Party since the first insists on a positive advo

41、cate forAll Party members and the self-discipline norms, moral declaration issued to all members of the party and the National Peoples solemn commitment. criterion of a clean and honest administration consists of 4 parts, 18, more than 3600 words. After the revision of the , a total of eight, 281 wo

42、rds, including lead, specification and Party member cadre clean fingered self-discipline norms, etc. Part 3 members low-cost clean and self-discipline, the main contents can be summarized as four must eight code. Lead part, reiterated on ideal and faith, fundamental purpose, the fine traditions and

43、work style, noble sentiments, such as four must the principle of requirements, strong tone of self-discipline, The higher request for 6 and supervised tenet, the foothold in permanent Bao the partys advanced nature and purity, to reflect the revised standards requirements. Members of self-discipline

44、 norms around the party members how to correctly treat and deal with the public and private, cheap and rot thrifty and extravagance bitter music, put forward the four norms. Party leader cadre clean fingered self-discipline norms for the leadership of the party members and cadres of the vital few, a

45、round the clean politics, from civil servant of the color, the exercise of power, moral integrity, a good family tradition and other aspects of the leadership of the party members and cadres of the four norms to fully adapt to the strictly requirements, reflects the according to the regulations governi