2022年服装QC常用语,服装品质控制常用语 .pdf

《2022年服装QC常用语,服装品质控制常用语 .pdf》由会员分享，可在线阅读，更多相关《2022年服装QC常用语,服装品质控制常用语 .pdf（4页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、服装 QC 常用语，服装品质控制常用语APPROVED SWATCH 已批的布办ART.NO./STYLE NO.款号AUTOLOCK ZIPPER 自动锁拉链BACK STITCHES 回针/返针BAD JOINED STITCHES 驳线不良BROKEN HOLE 破洞BROKEN STITCHES 断线BROKEN Y ARN 断纱BUBBLING 起泡BUMP AT PLACKET EDGE 筒边钮门位不顺直CENTER BACK RISE UP 后幅起吊CHECKS/STRIPES NOT MA TCH 格仔/条子不对称COLLAR POINTS HI/LOW 领尖高低COLOR F

2、ADING 褪色COLOR FAS TNESS PROBLEM 褪色问题COLOR FIBRE WOVEN IN 杂色纤维织入COLOR SHADING 色差COLOR THREAD LEFT INSIDE 藏色线COLOR TOO DULL/BRIGHT 颜色太哑/闪COLOR Y ARN 色纱COMBI PROGRAM 配色组合CONTRAST COLOR 撞色CREASE MARK 折痕CROCKING TEST 摩擦测试CROSSED BACK VENT 背叉搅CUFF EDGE NOT LEVELED 鸡英边高低DIRTY DOT（较小的）污点DIRTY MARK 污渍DIRTY S

3、POT（较大的）污点DROP TEST 跌落测试DRY RUB 干擦EXCESS EXTENSION 突咀FABRIC DEFECT 布疵FABRIC TOO CLOSED TO ZIPPER 面布车得太贴近拉链FLAP STRICKING UP 袋盖反翘FLUO.=FLUORESCENCE 荧光FLYING UP 飞起，翘起FTY.STICKER 工厂的贴纸GAPPING 藏木虱（烫工）GLAZE MARK（熨烫）起镜HEM NOT LEVELED 高低脚HI/LOW POCKET 高低袋HIKING A T BOTTOM OF PLACKET 前筒吊脚HIKING UP 起吊HORIZON

4、TAL SEAM NOT LEVELED 水平缝骨不对称INNER CUFF VISIBLE 介英反光IRON MARK 烫痕KNOT 结头LASTEST SIZE SPE CIF ICATION 最新的尺寸表LINING TOO FULL/TIGHT 里布太多/太紧MAJOR DEFECT 大疵MATCH COLOR 配色ATERIAL DEFECT 物料疵点MINOR DEFECT 小疵MIXED COLOR YARN 色纱NECK DROP PUCKER 筒顶起皱NEEDLE DAMAGE 针损坏布料NEEDLE HOLE 针孔OFF GRAIN 布纹歪OIL STAIN 油渍OPEN

5、SEAM 爆口OVERLAPPED COLLAR 叠领，踏领OVERLAPPED LIPS 叠唇OVERPRESS 熨烫过度OVERWASH 洗水过度PLACKET BOTTOM SPREAD OPEN 筒脚张开PLACKET W AVY 前筒起蛇（皱）PLEATED SEWING 打褶POCKET OPENING SPRAY OPEN 口袋“笑口”POOR BACK-STITCHES 回针不佳POOR IRONING 烫工不良PRESSING MARK 压痕PREVIOUS SHIPMENT 以前走的货PRODUCTION STATUS 生产情况PUCKER 起皱QC STICKER QC

6、贴纸，“鸡纸”RAW EDGE 散口RUN OFF STITCHES(车缝）落坑PRINTING SCRIMP 印花裂痕SEAM OVERTURN 止口反骨SEWN IN WASTE 车缝时混有杂物SHADING GARMENT TO GARMENT 衫与衫之间色差SHADING WITHIN 1PCS GARMENT 衣服裁片色差SHIPMENT UNDER CONSIGNMENT 寄卖SHORT SHIPMENT 短装SKIPPED STITCHES 跳线SLANTING POCKET 歪袋SLUB 毛粒SMILING POCKET 袋“笑口”STICKER 贴纸名师资料总结-精品资料欢迎

7、下载-名师精心整理-第 1 页，共 4 页 -STITCHES NOT IN SEAM SHADOW 缝线没被盖住STRIPES/CHECKS NOT MATCHING 不对条/格SUB-CONTRACTOR 外发厂SUBSTITUTE FABRIC 代用布SUPPORT SITCHES VISIBLE 辅助线外露FABRIC SWATCH 布办TENSION 张力THICK YARN 粗纱TOPPEST PLACKET PUCKER 筒顶起皱TOTAL DIFFERENT COLOR 颜色完全不同TRAPPED COLOR THREAD 藏色线TWIST 扭TWIST LEG 扭髀UNCUT

8、 THREAD ENDS 线头UNDER STITCHES VISIBLE 底线露出UNDERPL Y TURN OUT 反光UNDERPL Y VISIBLE OUTSIDE 反光UNDERPRESS 熨烫不够UN DES IREABLE ODOR 臭味，不可接受的气味UNEVEN COLLAR 歪领UNEVEN COLOR 深浅色UNEVEN LENGTH OF PLACKET 长短筒UNEVEN LENGTH OF SLEEVE 长短袖UNEVEN LIPS 大小唇UNEVEN STITCHING DENSITY 针步密度不均匀UNMA TCHED CROTCH CROSS 下裆十字骨错

9、位UNMEET BACK VENT 背叉豁WET RUB 湿擦WRONG COMBO 颜色组合错误WRONG PATTERN 图案错误WRONG SIZE INDICATED 错码YARN DRAWN OUT 抽纱ZIPPER NOT MOV ABLE 拉链不能拉验货用语资料成品检验 Checking of finished products 检验，检查inspection,check 商检 commodity inspection 领面松 wrinkles at top collar 领面紧 top collar appears tight 领面起泡crumples at top colla

10、r 领外口松collar edge appears loose 领外口紧collar edge appears tight 底领伸出collar band is longer than collar 底领缩进collar band is shorter than collar 底领里起皱wrinkles at collar band facing 底领外露collar band lean out of collar 倘领偏斜collar deviates from front center line 领窝不平creases below neckline 后领窝起涌bunches below b

11、ack neckline 驳头起皱wrinkles at top lapel 驳头反翘top lapel appears tight 驳头外口松lapel edge appears loose 驳头外口紧lapel edge appears tight 驳口不直lapel roll line is uneven 串口不直gorge line is uneven 领卡脖 tight neckline 领离脖 collar stand away from neck 小肩起皱puckers at shoulders 塌肩 wrinkles at shoulder 袖隆起皱creases at und

12、erarm 袖隆缝起皱puckers at underarm seam 塌胸 lack of fullness at chest 省尖起泡crumples at dart point 拉链起皱wrinkles at zip fly 止口不直front edge is uneven 止口缩角front edge is out of square 止口反翘front edge is upturned 止口反吐facing leans out of front edge 止口豁 split at front edge 止口下部搭叠过多crossing at front edge 底边起皱wrinkl

13、es at hem 后身起吊back of coat rides up 背衩豁开split at back vent 背衩搭叠过多crossing at back vent 绗棉起皱puckers at quilting 絮棉不均padded cotton is uneven 边缘缺棉empty hem 绱袖不圆顺diagonal wrinkles at sleeve cap 袖子偏前sleeve leans to front 袖子偏后sleeve leans to back 前袖缝外翻inseam leans to front 袖口起皱wrinkles at sleeve opening 袖

14、里拧 diagonal wrinkles at sleeve lining 袋盖反翘top flap appears tight 袋盖反吐flap lining leans out of edge 袋盖不直flap edge is uneven 袋口角起皱creases on two ends of pocket mouth 袋口裂 split at pocket mouth 腰头探出end of waistband is uneven 腰缝起皱wrinkles at waistband facing 里襟里起皱creases at right fly 夹裆 tight crotch 短裆 s

15、hort seat 后裆下垂slack seat 前浪不平wrinkles at front rise 名师资料总结-精品资料欢迎下载-名师精心整理-第 2 页，共 4 页 -裆缝断线bursting of crotch seam 裤脚前后two legs are uneven 脚口不齐leg opening is uneven 吊脚 pulling at outseam or inseam 烫迹线外撇crease line leans to outside 烫迹线内撇crease line leans to inside 腰缝下口涌bunches below waistline seam 裙

16、裥豁开split at lower part of skirt 裙身吊 split hem line rides up 裙浪不匀skirt flare is uneven 线路偏移stitch seam leans out line 双轨接线stitch seam is uneven 跳针skipping 尺码不符off size 缝制不良stitching quality is not good 洗水不良washing quality is not good 熨烫不良pressing quality is not good 极光 iron-shine 水渍 water stain 锈迹 ru

17、st 污渍 spot 色差 color shade,off shade,color deviation 褪色 fading,fugitive color 线头 thread residue 毛头 raw edge leans out of seam 绣花不良embroidery design out line is uncovered 织疵的英文表达梭织woven balling up 起球lint ball 起球pilling 起球ballooning 布面小圈flaw 织疵、疵点flying threads 布面拖纱float loop 蛛网entering draft 蛛网excessi

18、ve lift 多起bore 破洞duck eye 小洞（针织疵点）holes 破洞、破孔cut across 开匹（疵布）curling selvedge 卷边rolled selvedge 卷边baggy selvedge 松边loose edge/selvedge松边tight list/selvedge 紧边dog-legged selvedge 弯曲布边（由纬纱退绕张力引起）cut listing/selvedge 破边broken selvedge 破边ripped selvedge 破边torn selvedge 破边edge end break 坏边pilled-in selv

19、edge 缩边uneven selvedge 宽窄不匀布边rough selvedge 毛边hang pick 三角形破洞narrow width 布幅不足uneven cover 布面不匀rowdy 布面不匀wavy face 波浪形布面thick and thin places 厚薄段thick filling 粗经thread out 断经tight end/thread 紧经、急经tight filling/pick 紧纬、急经ridgy cloth 起伏不平的布slack selvedge 起伏不平的布边selvedge float 布边浮经丝 silk Gum knots 胶着类（

20、生丝疵点）Gummed books 丝把发硬Gummed skeins 丝胶发硬Double flat 双经/纬（生丝疵点）Double skeins 双片丝（生丝疵点）break-mark 灰点（绸缎疵点）broken course 断纬（丝）Cut ends 切丝Corkscrews 螺旋类（生丝疵点）Corkscrew twist 螺旋疵（捻丝疵点）Corkscrews yarn 螺旋线（并线疵点）Hairiness 毛羽类Heavy end 粗经Heavy filling/pick 粗纬Improper making of book 打把不正Improper skein lacking

21、 扣丝失当Improper skein twisting 打绞不正Irregular pick 纬疵Irregular pile bar 长短绒档Irregular skeins 丝绞不正Irregular traverse 络交不正Irregular twist streak 松紧捻档Knots 长结Knub 缫丝下脚，小糙疵Loops 环结Marriages 双丝名师资料总结-精品资料欢迎下载-名师精心整理-第 3 页，共 4 页 -Nap 绒毛、拉绒Pin hole 针洞Raised threads 浮丝其它others frosting 霜白疵、起霜花（印染引起）blur 剪毛不良ba

22、rring 条痕、条花bare cloth 稀布Broken figures 错花Crack 稀弄Cracked ends 筘痕Defective lift 夹起Darts and steels 刀线Decating mark 布头纬向皱横Duvet 小环结Fag 粗粒Facing 拖浆、罩色（印花疵点）Felter 跳花、跳纱harness skip跳花、跳纱Gout 飞花织入Loom fly 飞花织入Hard size 浆斑Joining stencil mark 搭头印（手工印花疵点）Keel 红印色Marking off 搭色Mildew 霉、生霉Minor defects 普通瑕疵、中类Major defects 次要瑕疵、大类Super major defects 主要瑕疵、特大类Mispick 错纬Weaving under 花纹少织（多梭箱织机的换纬运动不良造成）Starch lump 浆斑Start-up marks 开车痕Stripy defects 条花疵点Reed mark 筘痕Shuttle mark 局部纹路不明（主要由于开口运动或投梭失常所致）Snap/snappers 拖浆Stain warp 渍经Staining 斑点染色、染斑名师资料总结-精品资料欢迎下载-名师精心整理-第 4 页，共 4 页 -