地辐热施工方案.pdf

《地辐热施工方案.pdf》由会员分享，可在线阅读，更多相关《地辐热施工方案.pdf（9页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、word 目 录第一章、工程概况第二章、施工准备第三章、施工部署第四章、工艺流程第五章、质量标准第六章、应注意的质量问题第七章、安全文明施工第八章、成品保护word 第一章、工程概况西安市风憬天下16#楼项目，建筑结构类型：剪力墙结构；总建筑面积：28301.67，建筑高度：96.00m；地上 33 层，地下一层为自行车库，一至三十三层为普通住宅，住宅采暖为分户热计量形式，采暖立管设在水暖井内，采暖井内设两套采暖立管，采暖系统分高区（17-33 层），低区（1-16 层），户内采暖系统采用低温热水地板辐射采暖系统。热媒：55/45，热源由城市集中供热小区热换站提供，系统定压补水由热换站考虑。第

2、二章、施工准备1、班组施工前要了解建筑物的结构、熟悉设计图纸。施工方案及其它工种的配合措施。施工力量和机具等，能保证正常施工。施工现场、施工用水和用电、材料储备场地等临时设施，能满足施工需要。2、材料准备：1）加热管：PERT支管和盘管管材的型号，规格必须符合设计要求，并有产品出厂合格证及检验报告。2）聚苯板和铝箔：外观应平整，无污染、破损，绝热性能达到要求，有产品出厂合格证及检验报告。3）分集水器：设计为铜质分集水器，各配件应达到质量要求，接口完好无损，有产品出厂合格证及检验报告。4）辅助材料：钢丝网，塑料管卡、尼龙扎带、波纹管套等。3、作业条件：1)现场落地灰清理完成：基层要求干净、无杂物

3、堆放；室内墙体文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:C

4、Y3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 H

5、T8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO

6、7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码

7、:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9

8、 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1

9、ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3word 与地面交接处无落地灰，室内处理清洁，室内地辐热采暖以下基层平整度高低差在 10mm 以内。2）室内各部位建筑 50线到位，施工完成后能达到楼层层高要求。3）室内楼板内有强、弱电或其它管线敷设安装要求的，须完成穿引导线工作并通过验收。4）各层

10、回填混凝土施工管道的预留洞口做好成品保护，以便回填的正常施工。第三章、施工部署1、作业部署：土建墙体抹灰完成并通过验收，地面基层处理完毕，室内给水管和电气疏通完成通过验收后，进行室内地辐热安装施工。先进行支管安装，安装分集水器，然后敷设保温层和盘管。管间距小于等于10厘米或过墙处、或加伸缩缝处安装螺纹套管套管。系统安装完毕后，应进行水压试验，采暖试验压力：低区0.8MPa，高区 1.2MPa。打压试验通过后带压回填混凝土找平层，在施工找平层时，混凝土填充层浇注和养护过程中，地辐热采暖系统应保持不小于0.6MPa 的压力；填充层的养护，周期应不小于48 小时。验收合格后移交土建进行后续施工。第四

11、章、工艺流程1、支管施工管道井至户内的埋地管道用塑料涨管、自攻丝、塑料管卡固定在原楼地面上,钻孔时应注意电气预埋的线管。文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4

12、I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY

13、3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT

14、8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7

15、K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:

16、CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9

17、HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3word 2、分集水器的安装户内分、集水器的安装：分、集水器装置应固定于墙壁或专用的箱体内，在其附近及其他局部加热管道排列间距小于100mm 时

18、，加热管外部应设置柔性套管防止地面温度过高。集、分水器的每环供、回水支管均采用铜质阀门，以便于控制。集、分水器与管材连接处均应设柔性套管。3、保温层的铺设：自熄型聚苯乙烯保温板材，在一层敷设时采用 30mm 厚，在其他楼层敷设时采用20mm 厚。要求如下：盘管的铺设：1）、管道距墙尺寸不应小于100mm，放线时在满足施工图设计房间盘管间距原则的基础上根据现场实际情况予以合理调整。2）、按图纸要求铺设导热地盘管，质量要求：PERT管系列值为S4，使用条件为 4 级，在 60及 0.8MPa 的条件下使用寿命 50年。户内地盘管为 20*2.3,25*2.8，32*3.6 三种，PE-RT 导热地

19、盘管的弯曲半径不应小于6 倍管径，在铺设中直段管段不大于700mm内设固定管卡，弯曲管段沿走向距离不大于200300mm设固定管卡，用尼龙扎带固定在钢丝网上。3）、导热地盘管与分（集）水器连接前应测量好连接尺寸，用专用管剪断口，管口断面应垂直于管轴线，断口处应对残渣、毛刺进行修整清理，分（集）水器接口为卡箍式自锁紧连接件，将管头插入后拧紧锁母。螺纹套管的安装与处理：管间距小于等于10 厘米或过墙处、或文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N

20、9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1

21、 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文

22、档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L

23、6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1

24、N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S

25、3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O1

26、0L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3word 加伸缩缝处安装螺纹套管套管，穿墙套管出墙部分不少于5 厘米。打压试验：本工程自开始施工到交工验收共进行两次打压试验，每户管道全部安装完毕后，进行第一次压力实验：在进水口连接临时水源，打开进水球阀、排水球阀，注入清水、排水至出口水无可见颗粒物和气泡，即视为冲洗合格。然后存水打压，试压泵缓慢加压，升压时间不少于15 分钟，达到试验压力低区0.8Mpa 高区 1.2Mpa，在试验压力下，10min 内压力降不大于0.02MPa为合格。此项工作需经自检合

27、格后由监理验收，验收合格，方可进行下一道工序施工，此间需及时做好试压及冲洗自检记录。铺盖层的要求：地面应在沿墙以及过门口处设置膨胀缝，地板辐射采暖地面构造见暖施-02所示。采暖地板铺设在土壤上时，在绝热层以下应做防潮层；铺设在潮湿房间（如卫生间和厨房等），在填充层上部设置隔离层。加热管道应敷设在自熄型聚苯乙烯保温板材上。管道采用扎带绑扎固定。铺设保温板材时要求地面平整，无任何凹凸不平及沙石碎块、钢筋头等。钢筋头、电线管等管线只允许垂直穿过地板保温层。保温层用胶带粘牢接缝，加热盘管由远及近逐环铺设。4、带压回填混凝土垫层：混凝土填充层浇注和养护过程中，地辐热采暖系统应保持不小于0.6MPa的压力

28、；填充层的养护周期应不小于48 小时。铺盖层的要求：填充层采用 C15细石混凝土，施工时应确保工程质量，防止施工器械文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8

29、E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F

30、7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J

31、9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4

32、I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY

33、3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT

34、8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3word 对管材造成损伤。卵石粒经不大于12mm，并用水冲洗干净。采暖面积大于 30m2或边长超过 6m 时应按不大于 6m，间距设置伸缩逢，伸缩逢

35、宽度不应小于8mm，伸缩逢内填充弹性膨胀膏。当采用大理石和花岗岩等不允许留有明显缝隙的地面时,可将沿缝处板下部的角切去40，以留出变形空间。管道穿越伸缩缝时应加设长度不小于 200mm的柔性 PVC波纹套管，套管管径应为D32。5、验收交工：初次供暖调试时，应缓慢升温，先将水温控制在10C 环境温度范围内运行 48 小时，以后再每隔24 小时升温不超过5C，直至达到设计水温。地面辐射供热系统未经调试，严禁运行使用。运行期间，整个系统均如主管系统均不应有跑、冒、滴、漏等现象，各种阀门开闭灵活。第五章、质量标准按给排水与采暖工程施工工艺标准（ZJQ00-SG-010-2003）、建筑给排水及采暖工

36、程施工质量验收规范（GB50242-2002）、地面辐射供暖技术规程（JGJ142-2004）、建筑安装标准图集、采暖通风与空气调节设计规范GB50019-2003进行验收。1 主控项目：1）地辐热的管材规格型号，使用条件应符合设计要求。2）地辐热盘管的材料、规格，弯曲曲率半径应符合要求3）地辐热采暖系统的盘管在隐蔽前一定要进行试压试验，承压能力和严密性应符合要求。文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K

37、4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:C

38、Y3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 H

39、T8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO

40、7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码

41、:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9

42、 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1

43、ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3word 检查方法：检查资料，观察检查，尺量检测。2 一般项目：1）分、集水器安装应符合设计要求，放气阀及关断阀应进行验收。2）保温层的厚度、裁量的物理性能及敷设应符合设计要求。3）、盘管间距应符合设计要求，散热量符合设计要求。4）、填充层、面层施工技术要求及偏差要求符合规定。检查方法：观察，尺量检测。第六章、应注意的质量问题1、加热管安装时，应对材料的外观进行检查，并清除管道和管件内外的污垢和杂物。加热管的弯曲半径、PE-RT管不宜小于 6 倍管外径，不得出现“死折”。2、安装过程中，应防

44、止油漆、沥青或其它化学溶剂污染塑料类管道。3、管道系统安装间断或完毕的敝口处，应随时封堵。4、填充层内的加热管不得有接头。5、采用专用工具断管，断口应平整，断口面应垂直于管辐线。6、混凝土回填找平收面平整度和标高应符合要求。第七章、安全文明施工1、作业时着装应符合安全要求。2、禁止酒后作业。3、混凝土回填时应这注意成品保护，避免污染损坏。4、使用的作业工具，防止坠落伤人。第八章、成品保护1、施工进行盘管时需特别注意，不得撞击地面或用利器敲打地文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I

45、8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3

46、F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8

47、J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K

48、4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:C

49、Y3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 H

50、T8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO7K4I8E2S3文档编码:CY3F7O10L6N9 HT8J9C9L1N1 ZO