管道专业常用的英文及缩写词..doc

《管道专业常用的英文及缩写词..doc》由会员分享，可在线阅读，更多相关《管道专业常用的英文及缩写词..doc（43页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、北京石油化工设计院体系文件管道专业常用的英文及缩写词BPDI BE321321-05l 范围本文件规定了管道专业在设计文件上常用的英文及缩写词,在设计文件中使用的其它专业缩写词应按相关专业的规定执行。本文件适用于管道专业的设计工作。2 说明 本文件编制目的是为了统一用词和词的缩写,使设计文件的用词统一、标准并推荐在图纸上采用英文缩写词,尽量减少使用汉字,以利于国际交流。 文字说明和资料翻译时,应使用本规定的英汉对照词。3 按中文分类排列汉语词英语词英语缩写3.1 阀门类常用阀闸阀截止阀(球心阀)节流阀针型阀角阀(角式截止阀)Y型阀(Y型截止阀)球阀三通球阀蝶阀柱塞阀旋塞阀三通旋塞阀四通旋塞阀旋

2、塞隔膜阀夹紧式胶管阀止回阀Gate valveGlobe valveThrottle valveNeedle valveAngle valveY-valve(Y-boby globe valve)Ball valve3-Way ball valveButterfly valvePiston type valvePlug valve3-Way ball valve4-Way ball valveCockDiaphragm valvePinch valveCheck valveTRV汉语词英语词英语缩写其它阀平安泄汽阀(平安阀)平安泄液阀(卸荷阀)平安泄压阀罐底排污阀波纹管密封阀电磁阀电动阀气动阀

3、低温用阀蒸汽疏水阀呼吸阀减压阀控制阀调节阀不说明结构的阀切断阀手动控制阀调节阀快开阀隔断阀三通阀夹套阀排污阀排液阀放空阀卸载阀排出阀吸入阀多路阀取样阀手动阀旁路阀冲洗阀根部阀底阀3.2 管子与连接管子管子(标准规格)管子(非标规格)钢管铸铁管衬里管复合管(包复金属管)Safety valveRelief valveSafety relief valveFlush-bottom tank valveBellow sealed valveSolenoid valveElectrically operated valvePneumatic operated valveCryogenic servic

4、e valveSteam trapBreather valveReducing valveControl valveBlock valve, Shut-off valve ,Stop valveHand control valveRegulating valveQuick opening valveIsolating valve3-Way valveJacketed valveBlow down valveDrain valveVent valveUnloading valveDischarge valveSuction valveMultiport valveSampling valveHa

5、nd operated valve, Manually operated valveBy-pass valveFlush valveRoot valve, Primary valve, Header valveFoot valvePipeTubeSteel pipeCast iron pipeLined cining pipeClad pipeSVTRVHCVVTV汉语词英语词英语缩写碳钢管合金钢管不锈钢管奥氏体不锈钢管铁素体合金钢管无缝钢管焊接钢管镀锌钢管水煤气钢管塑料管玻璃管橡胶管壁厚系列号(管子表号)壁厚管子零件弯头异径弯头长半径弯头短半径弯头180弯头(回弯头)三通(T型三通)异径三通

6、等径三通45三通正三通(Y型三通)四通(十字通)异径管(大小头)同心异径管偏心异径管支管连接支管台(凹台)活接头管接头(管箍)管帽短节(短管)管堵(丝堵)焊接管帽盲板,管道盲板8字盲板特殊管件连接对焊的法兰的Carbon steel pipeAlloy steel pipeStainless steel valveAustenitic stainless steel pipeFerric alloy steel pipe Seamless steel pipeWelded steel pipe Water gas steel pipeGalvanized steel pipePlastic p

7、ipeGlass tubeRubber tubeSchedule numberWall thicknessElbowReducing elbowLong radius elbowShort radius elbowReturn elbowTeeReducing teeStraight tee45LateralTrue “YCrossReducerConcentric reducerEccentric reducerBranch connectionBossUnionCouling, Full couplingCapNipplePlugWelded capBlank, Blind, Line b

8、lankSpectacle blankSpecial pipe fittingsButt weldedFlangedLRESREREDCONECCCNIPPLGWCBW FLGD汉语词英语词英语缩写螺纹的承插焊的承插的对焊连接法兰连接螺纹连接管螺纹连接承插焊连接承插连接,套筒连接整体法兰螺纹法兰承插焊法兰松套法兰对焊法兰平焊法兰板式平焊法兰松套板式法兰滑套法兰(平焊法兰)法兰盖孔板法兰异径法兰螺栓圆直径法兰面光面,光滑面突面凹凸面凸面凹面榫槽面榫面槽面环连接面,梯型槽密封面全平面,满平面光滑突面螺栓热紧螺栓冷紧螺纹管帽螺纹焊管座承插焊管帽承插焊管座垫片非金属包覆垫片ThreadedSocket

9、 welded Belled Butt welded jointFlanged jointThreaded jointPipe threaded jointSocket welding flangeBell and spigot jointIntegral pipe flangeThreaded flangeSocket welding flangeLap joint flangeWeld neck flangeSlip on flange, Slip on weld flangeWelding plate flangeLoose plate flangeSlip-on-welding fla

10、ngeBlind flange, BlindOrifice flangeReducing flangeBolt circle diameterFlange facing, facing of flangePlain faceRaised faceMale-female(Seal contact)faceMale faceFemale faceTongue groove faceTongue faceGroove faceRing joint faceFlat face, Full faceSmooth raised faceBolt hot tighteningBolt cold tighte

11、ningThread capThread letSocket welded capSocket welded letGasketNon-metallic jacked gasketTHDSWBWTSWTHDFLJFWNFBCDFOFPFRF MFMMFFMFTGFTFGFRJFFFSRFTHDCTHLETSWCSWLET汉语词英语词英语缩写金属包覆垫片缠绕式垫片内环外环金属垫片3.3 管道附件组件气液别离器阻火器临时粗滤器永久粗滤器(固定粗滤器)Y型粗滤器T型粗滤器网状粗滤器粗滤器过滤器永久过滤器消音器(消声器)视镜浮球式视镜全视镜取样冷却器喷嘴,喷头喷射器洗眼器膨胀器(伸缩接头)波纹膨胀节球

12、型补偿器填函式补偿器平安淋浴器元件排液漏斗漏斗爆破板限流孔板混合孔板软管接头金属软管橡胶管挠性管(柔性管)快速接头旋转接头Metallic jacket gasketSpiral wound gasket Inner ringOuter ringMetallic gasketGas-liquid separationFlame arrested(Flame trap)Temporary strainetPermanent strainetY-type strainerT-type strainerGauge strainerStrainerFilterPermanent filterSilen

13、cerSight glass(Sight flow glass)Floating ball sight flow indicatorFull view sigh flow indicatorSample coolerSpray nozzleEjectorEye washerExpansion jointBellow expansion jointBall type expansion jointSlip type(packed type)expansion jointSafety showerDrain funnelFunnelRupture diskRestriction orificeMi

14、xing orificeHose connectionMetal hoseRubber hoseFlexible hoseQuick couplingSwivel jointRPROHC汉语词英语词英语缩写减压器3.4 材料 金属材料碳钢合金钢合金结构钢工具钢不锈钢奥氏体不锈钢马氏体不锈钢锻钢铸钢铸铁灰铸铁可锻铸铁球墨铸铁高硅铸铁铝铜黄铜铝镁合金蒙乃尔合金(镍铜合金)钛铅型钢角钢槽钢工字钢(工字梁)宽翼线工字钢(H钢)T字钢方钢扁钢园钢钢带钢板网纹钢板非金属材料塑料丙烯晴、丁二烯、苯乙烯橡胶聚乙烯聚氯乙烯ReducerCarbon steelAlloy steelStructural allo

15、y steelTool steelStainless steelAustenitic stainless steelMartensitic stainless steelForged steelCast steelCast ironGrey cast ironMalleable ironNodular cast iron, Nodular cast graphite ironHigh silicon cast ironAluminumCopperBrassAluminum magnesiumMonelTitaniumLeadShaped steelAngle steelChannelIBeam

16、Wide flanged beamTBarSquare BarFlat BarRound steel, rodStrap steelPlateCheckered platePlasticAcrylonitrile-butadiene-styrene rubberPolyethylenePloy vinyl chlorideREDABSPEPVC汉语词英语词英语缩写氯化聚氯乙烯聚丙烯聚苯乙烯氯化聚醚聚碳酸酯有机玻璃聚四氟乙烯碳纤维聚三氟氯乙烯氯化聚乙烯氯磺化聚乙烯环氧树脂泡沫聚苯乙烯玻璃纤维增强聚酯丁腈橡胶氯丁橡胶天然橡胶丁基橡胶丁苯橡胶顺丁橡胶不饱和聚酯聚氨酯耐火砖陶瓷搪瓷石棉3.5 设备安装

17、布置装置边界边界内边界外中心线接续线设备布置标高,高程,立面图绝对标高坐标坐标原点装置北真实北方位危险区Chlorinated ploy vinyl chloridePoly propylenePolystyreneChlorinated polyetherPolycarbonatePoly methyl methacrylatePolytetrafluoroethleneCarbon fiberPoly chlorotrifluoroethyleneChlorinated poly ethyleneChlorosulfonated polyethyleneEpoxy resinExpande

18、d poly styreneGlass fiber reinforced polyesterNitride butadiene rubberNeoprene rubberNatural rubberButyl rubberStyrene-Butadiene rubberCis-polybutadiene rubberUnsaturated polyesterPolyurethaneFire brickCeramicPorcelain enamelAsbestBattery limitInside battery limitOutside battery limitCenter lineMatc

19、h lineEquipment arrangement; Equipment layout; Plot PlanElevationAbsolute elevationCoordinateOrigin of coordinatePlant northtrue northOrientationHazardous areaCPVCPPPSCPEPCPMMAPTFECARPCTFECPE;CMCSM;CSPREPEPSFRPNBRNRPIBISBRCBRUPPUELTN汉语词英语词英语缩写铺砌区非铺砌区楼面地面标高平台场地管廊电缆槽(架)建筑物钢结构根底柱梁桁架墙篦子板吊装孔吊梁架顶面钢结构顶面混凝土

20、顶面梁顶面板外表吊勾顶面,上面底面,底下支撑点固定点建筑北设计北电缆沟管沟明沟明火地点散发火花地点防火间距支架间距地面坡度吊装孔道路地面内径外径汉语词Paving areaUnpaving areaFloorGround levelPlatformYardPipe rackCable tray(channel)BuildingSteel structureFoundationColun ; Post; StanchionBeamGirderWallGrate; GratingErection openingHoisting beamTop of supportTop of steelTop o

21、f concreteTop of BeamPlat faceHookTopBottomPoint of supportFixed pointConstruction northDesign northElectric cable duct; Electrical trenchPipe trenchOpen trenchOpen fire placeSend-out spark placeFire protection spacingSupport spacingGround gradeErection openingRoadGround; Ground levelInside Diameter

22、Outside Diameter英语词GLPFHBTOSTOSTOCTOBPLATFTOPBOTPOSFPDNGRDIDOD英语缩写公称直径公称压力切线中心线门窗地下底板底面控置室分析室配电室变压器室通风室更衣室贮藏室维修室盥洗室,厕所办工室门卫室,传达室接待室,会客室地秤室泵房压缩机室电池室消防栓电气盘仪表盘就地盘设备塔洗涤塔吸收塔冷却塔精馏塔换热器空冷器水冷却器冷却器螺旋板换热器套管换热器石墨换热器板片换热器汉语词Nominal diameter; Nominal(pipe)sizeNominal pressureTangent lineCenter lineGateWindowUnder

23、 groundBottom of base plateControl roomAnalyzerSubstationTransformer roomVentilation roomLocker roomStorage roomMaintenance roomCloste ; Toilet; WashroomOfficeEntrance guard room; Janitors roomReception roomWeigh-bridge roomPump house; Pump roomCompressor house(room)Battery roomFire plugElectrical p

24、anelInstrument panelLocal panelTower; ColumnScrubberAbsorberCooling towerFractionating towerHeat exchangerAir coolerWater coolerCondenserSpiral plate exchangerDouble pipe heat exchangerGraphite heat exchangerPlate type heat exchanger英语词DNPNTLUGBBPFPL英语缩写板翅式换热器板式塔填料塔浮阀塔反响器贮罐缓冲器混合罐浮顶罐内浮顶罐固定顶罐卧式储罐球罐罐,鼓

25、,筒,桶气柜螺旋式气柜湿式气柜干式气柜离心泵涡轮泵旋涡泵转子泵齿轮泵内啮合齿轮泵螺杆泵柱塞泵双作用往复泵计量泵,定量泵泥浆泵管道泵手摇泵深井泵输送泵屏蔽泵液下泵潜水泵多级泵立式泵磁力泵气动泵轴流泵混流泵Plate-fin heat exchangerPlate towerFloating distillation towerValve towerReactorTankKnock-out drumMixing tank(drum)Floating roof tank; Pontoon roof tankFloating internal roof tankStationary roof tank

26、Horizontal tankSpheroid; Spherical tankDrumGas holderHelical gas-holderWet gas holderDry gas-holderCentrifugal pumpTurbine pumpVortex pumpRotary pumpGear pumpInternal gear rotary pump; Crescen gear pumpScrew pumpPlunger pumpDouble action reciprocating pumpMetering pumpSlurry pump; Sludge pump; Mud p

27、umpInline pumpHand pump; Wobble pumpDeep well pumpTransfer pump; Delivery pumpShielding can-type pump; Canned pumpSubmerged pump; Submersible pumpSubmerged pump; Immersible pumpStage pump;, Multistage pumpVertical pump;Magnetic transmission pump; Magnetic coupled pumpPneumatic pumpAxial flow pumpMix

28、ed flow pump汉语词英语词英语缩写陶瓷泵陶制泵自吸泵消防泵真空泵叶片式真空泵水环式真空泵(压缩机)液环泵(压缩机)活塞式压缩机螺杆压缩机离心压缩机多级压缩机往复式压缩机风机,风扇鼓风机离心机离心别离机离心过滤机压滤机板框式压滤机厢式压滤机带式过滤机转鼓式过滤机盘式过滤机板式塔填料塔浮阀塔带式(皮带)运输机螺旋输送机加热器搅拌器炉子烟囱火炬锅炉发电机汽轮机电动机起重机,吊车板式起重机Ceramic pumpStoneware pumpSelf suction pump; self priming pumpFire pumpVacuum pumpVane vacuum pumpWater

29、 ring vacuum pump(compressor)Liquid ring pump(compressor)Piston compressorHelical screw compressorCentrifugal compressorMultiple stages compressorReciprocating compressorFan; VanBlowerCentrifugerCentrifugal separatorCentrifugal filterPressure filterPlate and frame filter pressBox type filer pressBel

30、t filterRotating drum type filterTray filterPlate towerPack tower; Packed columnValve tower; Floating distillation towerRibbon conveyer; Belt conveyerScrew convery ; Spirla conveyer; Worm conveyerHeaterAgitatorFurnaceStackFlareBoilerGeneratorSteam turbineMotorGraneBridge crane汉语词英语词英语缩写吊车梁电动葫芦成套设备附属

31、设备,附件枯燥器混合器蒸发器萃取器结晶器澄清器喷射器喷头别离器旋风别离器,旋风除尘器布袋收尘器电除尘器除尘器,吸尘器振动筛破碎机颚式破碎机粉碎机,磨碎机提升机,卷扬机斗式提升机电梯泡沫站软管站3.6 管道布置设计文件管道布置管道布置平面管道研究“X视图“A-A视图详图轴测图,空视图索引图接续图管道及仪表流程图工艺控制图工艺流程图汉语词Crane beam; Hoist beamMotor hoist; Electric hoist; Electric blockPackage unitAttachment equipmentDryerMixerEvaporatorExtractorCrysta

32、lligerGravity settlerEjectorSprayerSeparatorCyclone; Cyclone separator deviceCloth envelop collectionElectrostatic precipitator; Electridust precipitatorDuster; Dust arresterVibrating screen; Riddler; Oscillating sieveBreaker; Cracker mill; Crusher; Crushing millJaw breaker ;Jaw crusher; AlligatorGr

33、inder; Pulverizer; Disintegrator; AtomizerHoister; Lifter; Gig; ElevatorBucket elevatorElectrical lift; ElevatorFoam stationHose stationDesign documentPiping assembly; Piping layoutPiping arrangement planPiping studyView“xSection“A-ADetail drawingIsometric drawingKey planContinue on drawingPiping an

34、d Instrument diagramProcess control diagramProcess flow diagram英语词PAPCODP&ID英语缩写公用工程流程图总图总平面布置图放大图节点地上地下地面附图草图图例符号比例蒸汽伴管热水伴管电伴热夹套管高压中压低压大气，大气压工作压力，操作压力设计压力工作温度，操作温度设计温度管口取样接口去除口，清洗口排出口出口入口连接，接头管口方位排液放空污水坑，污水池地坑，井地漏下水管人孔手孔关闭后加铅封封关开启后加铅封封开汉语词Utility flow diagramGenera planGeneral arrangement planEnlar

35、ged viewNodeAbove groundUnder groundGroundFigueSketchLegendSymbolScaleSteam tracingHotwater tracingElectrical tracingJacketed tracingHigh pressureMedium pressureLow pressureAtmosphereOperating pressure; Working pressureDesign pressureOperating temperatureDesign temperatureNozzleSampling connectionCl

36、ean outExhaustOutlet; DischargeInlet; suctionConnectionNozzle orientationDrainVentSump pitPitFloor drainSewerManholeHandholeCar seal closeCar seal open英语词UFDAGUGGRDH.P.M.P.L.P.ATMDISCHINLETVENT英语缩写关闭后加锁锁关开启后加锁锁开正常时关闭正常时开启故障时关闭故障时开启垂直，正交平行管顶管底管内底底平顶平水平的，卧式的立式的，垂直的水平安装垂直安装管件直连管间距管道跨距管道等级管道材料规定等级分界隔热分界

37、管道附件管道元件面至面中心至面中心至中心中心至端面坡度公称直径公称压力外径内径螺栓圆直径软管接头管段，短管可拆短管直管弯管管内底标高汉语词Locked closedLocked openNormally closedNormally openValve closes on failure of actuating energyValve opens on failure of actuating energyPerpendicularParallelTop of pipeBottom of pipeInvert, Inside bottom of pipeFlat on bottomFlat

38、on topHorizontalVerticalHorizontal installationVertical installationFitting to fittingLine spacingLine spanPiping classPiping material specificationMaterial Specification breakInsulation breakPiping attachmentPiping elementFace to FaceCenter to FaceCenter to CenterCenter to EndSlope; GradeNominal DiameterNominal pressureOutside DiameterInside DiameterBolt circleHose connectionSpool piece; SpoolRemovable joint spoolRun pipe; Straight pipeBendInvert elevation英语词FCFO TOPBOPINVFOBFOTHORVERTFTFF-FC-FC-C