下氧化锆颗粒及碳纤维共混增强聚醚醚酮复合材料的摩.pdf

《下氧化锆颗粒及碳纤维共混增强聚醚醚酮复合材料的摩.pdf》由会员分享，可在线阅读，更多相关《下氧化锆颗粒及碳纤维共混增强聚醚醚酮复合材料的摩.pdf（6页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、?24?6?Vol.24 No.62 0 1 0?12?CHINESE JOURNAL OF MATERIALS RESEARCHDecember 2 0 1 0?(?110016)?(CF)?(ZrO2)?(PEEK)?,?,?,?,?,?,?,?,?,?PEEK?PEEK?,?,?,?,?,?,?TB332?1005-3093(2010)06-0625-06Study on the Tribological Properties of PolyetheretherketoneComposites Reinforced by ZrO2Particles and Short CarbonFib

2、ers under Water LubricationZHONG YingjieXIE GuangyouSUN ZhaosongSUI Guoxin(Institute of Metal Research,Chinese Academy of Sciences,Shenyang 110016)Manuscript received May 18,2010;in revised form June 24,2010.*To whom correspondence should be addressed,Tel:(024)83978040,Email:ABSTRACTPEEK matrix comp

3、osites filled with short carbon fibers(CF)and ZrO2particles werecompounded using a twin-screw extruder followed by injection molding.The tribological properties of thePEEK/CF/ZrO2composites under the water lubrication were systematically studied.It was revealed thatthe hybrid composites exhibit exce

4、llent wear-resistance in the water conditions.The friction coefficientsof the composites slightly changed with increasing of the applied load,while the wear rates of the hybridcomposites decreased with increasing applied load.Main wear mechanism of the composites in water wasmild abrasive wear and f

5、atigue wear.The high wear resistance of the composites should be attributed tothe existence of the carbon fibers:the carbon fibers carried the main load between the contact surfacesand protected the soft polymer matrix from further severe impact and abrasion of the counterpart.Theincorporation of th

6、e ZrO2particles could effectively inhibit the carbon fiber failure and debonding,whichresulted in a better wear resistance property of the hybrid PEEK composites compared with sole CFreinforced PEEK composites.However,high loading of the particles would also aggravate the fatigue wearof the composit

7、es and lead to a deterioration of the wear resistance of the composites.KEY WORDS composite,polyetheretherketone,friction and wear,hybrid reinforcement,carbon fiber,water lubrication?,?(PEEK)?,?13,?2010?5?18?;2010?6?24?:?,?,?,?4,?(?)?PEEK?626?24?626?24?626?24?,?(?);?PEEK?5,6?,?,?,?,?,?,?,?,?(CF)?,?,

8、CF?PEEK?,?7?,?,?8?,?,?,?,?912?,?,?,?,?,?(ZrO2)?,?PEEK/CF/ZrO2?,?,?1?PEEK?PEEK/30%CF?(ZrO2),?800 nm?PEEK?PEEK/30%CF?,?(PEEK/xCF/yZrO2,?x?CF?,y?ZrO2?)?150?6 h,?,?,?,?380?,?180?MM-W1A?,?1500#SiC?,?Ra=0.038m?,?,?18 MPa?,?,?(?METTLER AE240,?0.01 mg)?(K)?:K=mFNL(mm3N1m1)(1)?m?;?;FN?;L?,?2?2.1?1?PEEK/15CF/

9、15ZrO2?PEEK?PEEK/15CF/15ZrO2?1MPa?,?,?,?(?1a);?0.01?,?1.95108mm3/Nm?PEEK,?PEEK?,?(?1b)?2.2?PEEK/CF/ZrO2?,?,?13?,?,?,?14,15?,?PEEK/CF/ZrO2?PEEK/CF/10ZrO2?2?,?PEEK/6?:?6276?:?6276?:?627?1PEEK/15CF/15ZrO2?PEEK?:?;?:2 m/s;?:2 hFig.1 Effect of load on the tribological properties of PEEK/15CF/15ZrO2and ne

10、at PEEK.(a)wearrate and friction coefficient of PEEK/15CF/15ZrO2(b)wear rate of PEEK/15CF/15ZrO2andPEEK?2PEEK/CF/10 ZrO2?CF?:?;?:2 m/s;?:2 hFig.2 Effect of the CF content on the tribological properties of the PEEK/CF/10ZrO2composites.(a)friction coefficient(b)wear rate10ZrO2?,?4 MPa?,?,?2h?8 MPa?,?,

11、?,?,?,?,?0.02?,?CF?20%?,?,?PEEK/20CF/10ZrO2?8 MPa?6.19109mm3/Nm,?,?CF?,?PEEK/10ZrO2?PEEK/10CF/10ZrO2?4 MPa?SEM?3(a)?,?,?PEEK?,?,?,?,?3b?c?,?,?PEEK/10ZrO2?CF?,?,?,?628?24?628?24?628?24?3PEEK/10ZrO2?PEEK/10CF/10ZrO2?4MPa?:?;?:2 m/s;?:2 hFig.3 The typical morphologies on the worn sur-faces of PEEK/10Zr

12、O2and PEEK/10CF/10ZrO2compositeunder4MPa.(a)PEEK/10CF/10ZrO2(b)PEEK/10ZrO2(c)PEEK/10ZrO2?CF?2.3?PEEK/CF/ZrO2?4?PEEK/10CF/ZrO2?4a?,PEEK/10CF?,?,?1 MPa?,?;?4b?4PEEK/10CF/ZrO2?ZrO2?.?:?;?:2 m/s;?:2 hFig.4 Effect of ZrO2content on the tribologicalproperties of the PEEK/10CF/ZrO2compos-ites.(a)friction c

13、oefficient(b)wear rate?W?,?1 MPa?,?5%?,PEEK/10CF/5ZrO2?PEEK/10CF?,?10%?,?,?15%,?,?20%?,?,?PEEK/10CF/5ZrO2?PEEK/10CF?SEM?5a?5b?,?8 MPa?,PEEK/10CF?,?PEEK/10CF/5ZrO2?,?5%?,?10,16?,?,?6?:?6296?:?6296?:?629?5PEEK/10CF/5ZrO2?PEEK/10CF?8 MPa?:?;?:2 m/s;?:2 hFig.5 The morphologies of the worn surfaces of PE

14、EK/10CF/5ZrO2and PEEK/10CF composites.(a)PEEK/10CF/5ZrO2(b)PEEK/10CF?6PEEK/10CF/5ZrO2?PEEK/10CF/10ZrO2?1 MPa?:?;?:2 m/s;?:2 hFig.6 The morphologies of worn surfaces of PEEK/10CF/5ZrO2and PEEK/10CF/10ZrO2compos-ites at 1 MPa.(a)PEEK/10CF/5ZrO2(b)PEEK/10CF/10ZrO2(c)PEEK/10CF/5ZrO2(d)PEEK/10CF/10ZrO2?1

15、PEEK/CF/ZrO2?Table 1 The micro-hardness of PEEK/CF/ZrO2compositesMaterial(PEEK/CF/ZrO2)90/5/585/5/1080/5/1575/5/20Micro-hardness,kg/mm327.60.828.81.330.91.432.31.0?,?,?,?,?,?,?,?(?5a,5b),?:?,?1?,?,?,Zhang?12?,?,?,?,?,?,?,?,?630?24?630?24?630?24?,?SEM?,?6?PEEK/10CF/5ZrO2?PEEK/10CF/10ZrO2?1 MPa?6a?6b?

16、,?,?,?,?;?6b?,?,?6c?6d?,PEEK/10CF/10ZrO2?,?,?,?,?,?,?,?,?,?W?(?4b?)?3?1.?,PEEK/CF/ZrO2?2.?,?,?3.?,?,?,?1JIAO Sujuan,ZHOU Hua,YANG Huayong,GONG Guo-fang,CHEN Jianmin,ZHOU Huidi,Tribological Behav-ior of Filled Polyetheretherketone Composites in Slidingagainst Stainless Steel under Water Lubrication,T

17、ribol-ogy,23(5),385(2003)(?,?,?,?,?,?,?,?,23(5),385(2003)2PAN Yusong,XIONG Dangsheng,Rsearch status of tribo-logical properties of PEEK composites,Engineering Plas-tics Application,34(2),68(2006)(?,?,?,?,34(2),68(2006)3ZHANG Zhiyi,ZHANG Mingqiu,ZENG Hanmin,LIUZhengrang,On the tribological behaviour

18、and mechanismof poly(ether ether ketone),Acta Materiae CompositaeSinica,12(4),49(1995)(?,?,?,?,?,?,12(4),49(1995)4R.Prehn,F.Haupert,K.Friedrich,Sliding wear perfor-mance of polymer composites under abrasive and waterlubricated conditions for pump applications,Wear,259,693-696(2005)5Y.Yamamoto,T.Taka

19、shima,Friction and wear of waterlubricated PEEK and PPS sliding contacts,Wear,253,820-826(2002)6Y.Yamamoto,M.Hashimoto,Friction and wear of wa-ter lubricated PEEK and PPS sliding contactsPart 2.Composites with carbon or glass fibre,Wear,257,181-189(2004)7H.Unal,A.Mimaroglu,Friction and wear characte

20、ristics ofPEEK and its composite under water lubrication,Jour-nal of Reinforced Plastics and Composites,25,16591667(2006)8J.P.Davim,N.Marques,A.M.Baptista,Effect of carbonfibre reinforcement in the frictional behaviour of Peekin a water lubricated environment,Wear,251,1100-1104(2001)9L.Chang,Z.Zhang

21、,C.Breidt,K.Friedrich,Tribologicalproperties of epoxy nanocompositesI.Enhancement ofthe wear resistance by nano-TiO2particles,Wear,258,141-148(2005)10L.Chang,Z.Zhang,TribologicalpropertiesofepoxynanocompositesPart II.A combinative effect of short car-bon fibre with nano-TiO2,Wear,260,869878(2006)11L

22、.Chang,Z.Zhang,L.Ye,K.Friedrich,Tribological prop-erties of high temperature resistant polymer compositeswith fine particles,Tribology International,40,1170-1178(2007)12G.Zhang,L.Chang,A.K.Schlarb,The roles of nanoSiO2particles on the tribological behavior of short carbon fiberreinforced PEEK,Compos

23、ites Science and Technology,69,1029-1035(2009)13J.X.Wang,M.Y.Gu,Wear properties and mechanisms ofnylon and carbon-fiber-reinforced nylon in dry and wetconditions,Journal of Applied Polymer Science,93,789-795(2004)14A.Borruto,G.Crivellone,F.Marani,Influence of surfacewettability on friction and wear

24、tests,Wear,222,57-65(1998)15J.Jia,J.Chen,H.Zhou,L.Hu,Comparative study on tri-bological behaviors of polyetheretherketone composite re-inforced with carbon fiber and polytetrafluoroethylene un-der water-lubricated and dry-sliding against stainless steel,Tribology Letters,17,231-238(2004)16Z.Y.Jiang,L.A.Gyurova,A.K.Schlarb,K.Friedrich,Z.Zhang,Studyonfrictionandwearbehaviorofpolyphenylenesulfidecomposites reinforced byshortcarbon fibers and sub-micro TiO2 particles,CompositesScience and Technology,68,734-742(2008)