工艺管道等级汇总表.xls

《工艺管道等级汇总表.xls》由会员分享，可在线阅读，更多相关《工艺管道等级汇总表.xls（14页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、管 道 施 工 手 册Piping Construction Manuel4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RANGE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)A1A150 RFCS碳钢-10 到 371ATMOSPHERIC VENT大气放空,PLANT AIR工业风,CALCIUM HYDROXIDE氢氧化钙 氢氧化钙(LIME石灰),DECOKING AIR脱焦气,DILUTION STEAM稀释蒸汽,SAFETY VENT 安全放空LBW(DEAERATE

2、D),LBW(已脱氧)OILY-DRAIN含油液LP STEAM低压蒸汽,LP CONDENSATE低压冷凝液FUEL GAS燃料气,FUEL OIL燃料油,NITROGEN氮气,COOLING WATER SUPPLY冷却水供给,RETURN回流,INTERMEDIATE 过渡物流(AG)(UG),CONTAMINATED WATER污水(AG)(UG),惰性气体,NON-CONTAMINATED WATER非污染水,WASTE WATER废水,FIREWATER 消防水(AG),OILY WATER SEWER 含油污水(UG)CHILLED WATER,DECANTED WATER,PR

3、OCESS WATERA1A20 150RFCS碳钢-20 到 370ATMOSPHERIC VENT放空 OILY WATER SEWER污油水LP STEAM低压蒸汽 FUEL GAS燃料气 LP DENSATE低压冷凝物 COOLING WATER 冷却水A1AA150 RFCS碳钢0 到 66COOLING WATER冷却水UTILITY WATER公用工程用水A1D150 RFCS碳钢-10到 427EB,ORGANICS有机物,HYDROCARBON烃,QUENCHOIL急冷油,STYRENE FEED苯乙烯进料,DEVOL脱挥发份,RUBBER SLURRY橡胶渣泥OLIGMER

4、S低聚物,A1D20 150RFCS碳钢-20 到 370HYDROCARBON 碳氢化合物 QUENCH OIL急冷油A1E150 RFCS碳钢-10 到316HYDROGEN氢气A1E20PN2.0 RF(150RF)CS碳钢-10 到200HYDROGEN氢气A1F150 RFCS碳钢-10到 51.593 到 98%SULFURIC ACID93到 98%硫酸A1F20PN2.0 RF(150RF)CS碳钢-20 到 20093 到 98%SULFURIC ACID93到 98%硫酸A1J150 RFCS碳钢-10 到 316BT EXTRACTION w/VACUUM抽提及/真空A1

5、K150 RFCS碳钢-10 到260WET/HOT FLARE干湿火炬A1K20PN2.0 RF(150RF)CS碳钢-10 到 260WET/HOT FLARE干湿火炬A1NR150 RFCS碳钢-10到110SPENT CAUSTIC废碱HYDROCARBON(WITH CAUSTIC&5%BENZENE苯A1NR20PN2.0 RF(150RF)CS碳钢-20 到 110SPENT CAUSTIC (50%Caustic)废碱A1P150 RFCS碳钢-10到 427TRANSFER LINES传送管线HYDROCARBON 烃A1PA150 RFCS碳钢-10到427DECOKING

6、 LINES,脱焦VACUUM SERVICES负压介质A1WR150 RFCS碳钢-10 到260STABILIZER COLUMN OVHD(H2S ENVIRONMENT)稳定器塔塔顶(H2S环境)A1X150 RFCS碳钢-10 到371?PROCESS LIQUID&VAPOUR(LETHAL W/HCN),工艺液体及蒸汽(致命性物料及HCN),OFFTEST ACRYLONITRILE未检验丙烯腈PARTIAL VAC CLOSED DRN部分负压倒淋关闭,LIQUID&VAPOUR(LETHAL-5.7PAIS)1管 道 施 工 手 册Piping Construction Ma

7、nuel液体及蒸汽(致命物料-5.7PAIS)A1Y150 RFCS碳钢-10 到 371?PROCESS VAPOUR LETHAL(FULL VAC,ACRYLO&WTR)工艺蒸汽致命性物料(全负压)CATALYST(FULL VAC AT CATALYST HOPPERS)催化剂(催化剂料斗全负压)A2A150 RFLTCS-46到 260COLD FLARE冷火炬,ETHYLENE REFRIG.制冷乙烯,L.T.HYDROCARBON低温烃,LIQUID DRAIN液体倒淋,PPL REFRIGERANT制冷剂A6A150 RFLINED CS衬碳钢 -17 到 93BCHLORIN

8、ATED WATER含氯水CHLORINE DIOXIDE二氧化氯DILUTE H2SO4 PARTIAL FLOW W/AIR,稀释液H2SO4 部分液流及/空气FERRIC CHLORIDE氯化铁,SODIUM CHLORIDE氯化钠SODIUM CHLORIDE氯化钠,SODIUM BISULFITE二硫化钠,SODIUM HYPOCHLORITEACID DRAINS(98%H2S04)SULFURIC ACID(A/GRDonly)次氯酸钠倒淋(98%H2S04)硫酸(仅A/GRD)HYDROCHLORIC ACID(31%)盐酸A6A20PN2.0 RF(150RF)LINED C

9、S(PVDF)-20 到 93BCHLORINATED WATER 氯水CHLORINE DIOXIDE 氯酸DILUTE H2SO4 PARTIAL FLOW W/AIR稀硫酸FERRIC CHLORIDE SODIUM CHLORIDE SODIUMBISULFITE SODIUM HYPOCHLORITE ACID DRAINS(98%H2S04)SULFURIC ACID(A/GRD only)浓硫酸A21A150 RFLJ304 SS-29 到 204DEMINERALIZED WATER(NON-DEAERATED BFW)PHOSPHATE磷酸盐,NSIA21A19PN2.0 R

10、F1500Cr19Ni9S/Stl-29 到204DEMINERALIZED WATER 软水A21B150 RFWN304 SS-29 到 204BIOCIDE SOLUTION除菌溶液DISPERSANT扩散剂,CORROSION INHIBI到R防腐剂PHOSPHATE磷酸盐,NSIA21B19PN2.0RFLJ(150#)0Cr19Ni9S/Stl-29 到204BIOCIDE SOLUTION除菌溶液CORROSION INHIBI到R防腐剂DISPERSANT扩散剂,PHOSPHATEA21C150 RFLJ304 SS-29 到 204HYDRAZINE肼A21D150 RFLJ

11、304 SS-29 到 204LUBE AND SEAL OIL润滑及密封油(HIGH AND LOW PRESSURE)高压和低压A21K150 RFWN304 SS-101到 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃A21K19PN2.0RFWN(150RF)0Cr19Ni9S/Stl-101 到 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃A21L150 RFWN304 SS-196到204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROC

12、ARBON低温烃A21L19PN2.0RFWN(150RF)0Cr19Ni9S/Stl-196 到 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RANGE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)2管 道 施 工 手 册Piping Construction ManuelA22A150 RF304(L)SS-29 到 160?GASEOUS OXYGEN PROCESS L

13、IQUID/VAPOURCLOSED DRAIN气态氧工艺流体蒸汽倒淋关闭A22D150 RFLJ304(L)SS-13 到 150?POWDER&PELLET CONVEYING粉粒料传输A22E150 RFLJ304(L)SS-13 到 140?POWDER&PELLET粉及粒料(GRAVITY重力传输),POLYETHYLENE PELLET聚乙烯粒料PELLET ADDITIVE粒料添加剂A22F150 RFWN304(L)SS-13 到 65?CATALYST CONVEYING VENT催化剂输送放空,POLYSTYRENE VENT聚苯乙烯放空A22G150 RFLJ304(L)

14、SS-13 到 140POWDER&PELLET(GRAVITY)粉粒料(重力传输)CONVEYING AIR传输空气A22H150 RFLJ304(L)SS-13 到140?POWDER/PELLET(GRAVITY LINES)粉粒料PELLET ADDITIVE粒料添加剂POWDER粉料,POLYETHYLENE PELLET聚乙烯粒料A23L150 RFLJ316(L)SS0 到 300?SOFTENED WATER软化水STYRENE苯乙烯COLD DEMIN WATER冷却脱盐水A23L17 RF15000Cr17Ni14Mo2 S/Stl0 到 300?SOFTENED WATE

15、R COLD DEMIN WATER STYRENEA24A150 RFLJ316(L)SS-29 到 160BSULPHUR DIOXIDE 二氧化硫(DRY干态)PHOSPHATE磷酸盐,AMINE胺,MAC +H2O M酸+H2OCRUDE&WEAK MAC原M酸及弱M酸ACRYLIC/ACETIC ACID丙烯酸/醋酸A24B17PN2.0 RFLJ(150#)00Cr17Ni14Mo2 S/Stl-29 到200?AMINE胺,PHOSPHATE磷酸盐MAC +H2O M酸+H2OCRUDE&WEAK MAC原M酸及弱M酸ACRYLIC/ACETIC ACID丙烯酸/醋酸A24C15

16、0 RF316(L)SS-29 到 204?GLYCOL ACID 乙二醇酸PROCESS FLARE(LETHAL HCN)工艺火炬(致命性 HCN)PROCESS LIQUID/VAPOUR(LETHAL&CORROSIVEHCN)工艺流体/蒸汽(致命性及腐蚀性HCN)A24C17 150RF00Cr17Ni14Mo2 S/Stl-29 到 200?GLYCOL ACID 乙二醇酸PROCESS FLARE(LETHAL HCN)工艺火炬(致命性 HCN)PROCESS LIQUID/VAPOUR(LETHAL&CORROSIVEHCN)工艺流体/蒸汽(致命性及腐蚀性HCN)A92L300

17、RF316(L)SS-29 到 315?POLYMER聚合物A92L17300RF00Cr17Ni14Mo2 S/Stl-29 到 315?POLYMERB1A300 RFCS碳钢-10 到 427IIIBOILER BLOWDOWN锅炉排放物 FUEL OIL燃料油低压锅炉进水(LBW),LP BOILER FEED WATER(LBW)STEAM蒸汽,CONDENSATE冷凝液B1A20PN5.0 RF(300RF)CS碳钢-10 到 425IIIBOILER BLOWDOWN锅炉排放物LP BOILER FEED WATER(LBW)低压锅炉进水(LBW)STEAM蒸汽,CONDENSA

18、TE冷凝液B1D300 RFCS碳钢-10 到 427IIIHYDROCARBON,QUENCH OIL,1st PREPOLY,EB烃，冷脆油，预聚物，乙苯B1D20300RFCS碳钢-10 到 425IIIHYDROCARBON,烃 QUENCH OIL,急冷油B1E300 RFCS碳钢-10 到 274III(FEED&PRODUCT)进料气及产品气HYDROGEN 氢气4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RANGE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)3

19、管 道 施 工 手 册Piping Construction ManuelB1E20 300RFCS碳钢-10 到 274IIIHYDROGEN(FEED&PRODUCT)B1J300 RFCS碳钢-10 到 316IIIBT EXTRACTION w/VACUUMBT抽提 及负压B1NR300 RFCS碳钢-10 到 110IIISPENT CAUSTIC废碱B1NR20 RF 300RFCS碳钢-20 到 110IIISPENT CAUSTICB1X300 RFCS碳钢-13 到 230?PROCESS GAS&POLYMER FINE工艺气体及精制聚合物PROCESS LIQUID工艺流

20、体RELIEF VENT泄压放空B1X20PN5.0 RF(300RF)CS碳钢-13 到 250?PROCESS GAS&POLYMER FINE 聚乙烯PROCESS LIQUID 工艺流体 RELIEF VENT泄压放空B2A300 RFLTCS低温碳钢-46 到 316?COLD FLARE冷火炬 ETHYLENE REFRIG.制冷乙烯LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃,PROPYLENE REFRIG.制冷聚丙烯B8K300RF304H SS20 到 704?SUPERHEATED STEAM过热蒸汽 SUPERHEATED STEAM(dehy

21、dro reac到r)B21D300 RF304 SS-29 到 204LUBE AND SEAL OIL润滑油及密封油B21K300 RF304 SS-101 到 204COLD FLARE冷火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃B21K19PN5.0300RF0Cr19Ni9S/Stl-101 到 204LIQUID DRAIN 排污 L.T.HYDROCARBON 低温乙烯B21L300 RF304 SS-196 到 204COLD FLARE冷火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃B21L19PN5.0300R

22、F0Cr19Ni9S/Stl-196 到 204 LIQUID DRAI L.T.HYDROCARBON 低温乙烯304(L)SS-46 到130PROCESS LIQUID(low temp)工艺流体(低温)PURE HP NITROGEN纯高压氮气PROCESS GAS工艺气体B21W19PN5.0300RF0Cr19Ni9S/Stl-46 到 150？PROCESS GAS 工艺气体PROCESS LIQUID(low temp)PURE HP NITROGENB21X300 RF304(L)SS-13 到 130？PROPYLEN丙烯+POLYPRO POWDER,POWDER粉粒PR

23、OCESS GAS&POLYMER FINE气体及精制聚合物B22A300 RF304(L)SS-53 到 49？BARGE FLARE浮动码头火炬PROCESS LIQUID 工艺流体(LT PROPYLENE低温丙烯),PROCESS VAPOUR工艺蒸汽(PROPYLENE丙烯)B22A19 RF 30000Cr19Ni10S/Stl-53 到 100？BARGE FLARE 火焰 PROCESS LIQUID 工艺流体B23L300RF316(L)-50/AMB？STYRENE VAPOUR苯乙烯蒸汽,B23L17300 RF00Cr17Ni14Mo2 S/Stl-50/AMB&350

24、？STYRENE VAPOUR 苯乙烯蒸汽 WET GAS湿气B54A300 RF1-1/4 CR1/2Mo-29 到 538 H.T.TRANSFER LINES高温传输管线,B54A15PN5.0 RF(300RF)15CrMo-29 到 500HYDROCARBON烃,H.T.TRANSFER LINES HIGHPRESSURE STEAM高温蒸汽B92A300 RFCS碳钢-29 到 315？POLYMER 聚合物 2nd PREPOLY BOT到MSD1A600 RFCS碳钢-10 到 427BBOILER FEED WATER锅炉进料水,STEAM蒸汽CONDENSATE CIR

25、CULATING COOLANT冷凝液循环冷却剂 PROCESS WATER INJECTIOND1A20PN10.0 RF(600RF)CS碳钢-10 到425BBOILER FEED WATER,STEAM,CONDENSATECIRCULATING COOLANTD1AS600 RFCS碳钢0 到 343？BOILER FEED WATER 锅炉进水,STEAM蒸汽4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RANGE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)4管 道

26、 施 工 手 册Piping Construction ManuelCIRCULATING COOLANT循环冷却剂D1D600 RFCS碳钢-10 到 427HYDROCARBON烃D1E600 RFCS碳钢-10 到 204HYDROGEN氢气D1W600 RFCS碳钢-13 到 325?HP HYDROGEN高压氢气,KILLER GAS抑制气体PROCESS GAS(non corr),工艺气体(非腐蚀性)ETHYLENE乙烯,PROCESS LIQUID工艺流体D2W600 RFLTCStl-46 到 325?PROCESS LIQUID工艺流体,ETHYLENE乙烯D22C600

27、T&G304(L)-13 到 150?TEAD22D600 RF304(L)-46 到 170?CATALYST催化剂PROCESS GAS工艺气体,PROCESS LIQUID工艺流体PROCESS GAS(non corr)工艺气体(非腐蚀性)PROCESS LIQUID工艺流体(low temp低温)工艺流体(低温)KILLER GAS抑制气体D22E600 RF304(L)0 到 93?WASTE WATER 废水,工艺流体/蒸汽(腐蚀性)PROCESS LIQUID/VAPOUR(CORROSIVE)D26A600 RF321 SSSTABILIZED-29 到 427?HYDROG

28、ENATION加氢,PYROLYSIS GAS裂解气,SECOND STAGE REAC到R二级反应器D54A600 RF1-1/4 CR1/2Mo-29 到 538HIGH PRESSURE STEAM高压蒸汽D54A15 600RF15CrMo-46 到 316HIGH PRESSURE STEAMD54E600 RF1-1/4 CR1/2Mo-29 到 538HYDROGEN氢气D92A600 RFCS碳钢315?POLYMER聚合物E1D900 RFCS碳钢-10 到 427ETHYLENE PRODUCT乙烯产品,PROPYLENE PRODUCT丙烯产品E2A900 RFLTCS-

29、46 到 316ETHYLENE REFRIG乙烯,LIQUID DRAIN,液体倒淋PROPYLENE REFRIG制冷丙烯.E21K900 RF304 SS-101 到 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃,DEMIN WATER INJECTION注入脱盐水E92A900 RFCS碳钢-10 到 315?POLYMER聚合物-1st STAGE DEVOL BOT到MS聚合物 一级脱挥发份残渣F1A1500 BWCS碳钢-10 到 427BOILER FEED WATER锅炉进水,CONDENSATE冷凝液F1AS1500

30、 BWCS碳钢-10 到 359BOILER FEED WATER锅炉进水,CONDENSATE冷凝液F1D1500 BWCS碳钢-10 到 427HYDROCARBON烃F2A1500 BWLTCS低温碳钢-46 到 316ETHYLENE EFRIGERATION制冷乙烯,LIQUID DRAIN倒淋,PROPYLENE REFRIGERATION制冷丙烯F21B1500 BW304 SS-29 到 371PHOSPHATE磷酸盐F21K1500 BW304 SS-101 到 204LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃F23Z1500316 SS-49 到

31、 50VTKILLER GAS 抑制气体LUBE OIL润滑油SILANE硅烷F54AS1500 BW1-1/4 CR1/2Mo-29 到 538VIIDESUPERHEATED STEAM脱过热蒸汽F93L300 INNER&OUTER316(L)SSHOLD待定?ZINC STEREATE硬脂酸锌G54A2500 BW1-1/4 CR1/2Mo-29 到 538 VIVERY HIGH PRESS STEAM较高压蒸汽D1AS600 RFCS碳钢0 到 343？4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RAN

32、GE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)5管 道 施 工 手 册Piping Construction ManuelG54AS2500 BW1-1/4 CR1/2Mo-29 到 538VIIIVERY HIGH PRESS STEAM较高压蒸汽G92A2500INNER 300OUTERCS碳钢-10 到 315?POLYMER-2nd STAGE DEVOL BOT到MSH3A150 RFCS碳钢(GALV.)-10 到 121 IIINSTRUMENT AIR仪表风,POTABLE WATER饮用水H3A20PN2.0 RF(150RF)CS

33、 (GALV)-20 到 121 IIINSTRUMENT AIR POTABLE WATERH44C150 RFC/Stl 碳钢 (衬水泥)-29 到 66VTFIRE WATER消防水(UG)H44C20 20#C/Stl(CEMENTLINED)-29 到 66VTFIRE WATER(UG)H61B0.345 MPaFRP玻璃钢-29 到 43VTS到RM WATER SEWER雨水(UG)S2HD300 RFINCOLOY800HT20 到885?SUPERHEATED STEAM耐热合金800HT过热蒸汽S82CTUBING管316 SS-29 到 649VTCORROSION I

34、NHIBI到R防腐剂STEAM TRACING蒸汽伴热HC SAMPLING取样,T62A150 FFPVCAMB 到 60VTCHEMICAL DRAIN化学剂倒淋SANITARY SEWER 污水GENERATION WASTE脱盐再生废液4、工工艺艺管管道道等等级级汇汇总总表表CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMP RANGE(C)NDECLASS探探伤伤等等级级SERVICE 介介质质温温度度范范围围(C)6CLASS等等级级RATING额额定定值值PIPEMATL管管道道材材质质TEMPERATURERANGE(C)SERVICE 介介质质

35、温温度度范范围围(C)A1A150 RFCS碳钢-10 到 371ATMOSPHERIC VENT大气放空,CALCIUM HYDROXIDE 氢氧化钙(LIME石灰),DECOKING AIR脱焦气,DILUTION STEAM稀释蒸汽,LBW(DEAERATED),LBW(已脱氧)LP STEAM低压蒸汽,LP CONDENSATE低压冷凝液FUEL GAS燃料气,FUEL OIL燃料油,NITROGEN氮气,OILY-DRAIN含油排放液,SAFETY VENT 安全放空COOLING WATER SUPPLY冷却水供给,RETURN回流,INTERMEDIATE 过渡物流(AG)(UG

36、),INERT GAS(AG)(UG),惰性气体,CONTAMINATED WATER污水NON-CONTAMINATED WATER非污染水,PLANT AIR工业风,WASTE WATER废水,FIREWATER 消防水(AG),OILY WATER SEWER 含油污水(UG)CHILLEDWATER,DECANTED WATER,PROCESS WATERA1A20PN2.0RF(150RF)CS-20 TO 370ATMOSPHERIC VENT OILY WATER SEWER(UG)LP STEAM,FUEL GAS LPCONDENSATE FUEL OILNITROGEN P

37、LANT AIRCOOLING WATER SUPPLY,RETURN,INTERMEDIATE(UG)A1AA150 RFCS碳钢0 TO 66COOLING WATER冷却水UTILITY WATER公用工程用水A1AA20150RFCS-10 TO 150COOLING WATER UTILITY WATERA1D150 RFCS碳钢-10 TO 427EB,ORGANICS有机物,HYDROCARBON烃,QUENCH OIL急冷油,STYRENE FEED苯乙烯进料,DEVOL脱挥发份,-10至 427OLIGMERS低聚物,RUBBER SLURRY橡胶渣泥A1D20PN2.0RF

38、(150RF)CS-20 TO 370HYDROCARBON QUENCH OILA1E150 RFCS碳钢-10 TO 316HYDROGEN氢气-10 至316A1E20PN2.0RF(150RF)CS-10 TO200HYDROGENA1F150 RFCS碳钢-10 TO 51.593 to 98%SULFURIC ACID-10至 51.593至 98%硫酸A1F20PN2.0RF(150RF)CS-20 TO 20093 to 98%SULFURIC ACIDA1J150 RFCS碳钢-10 TO 316(FULLVACUUMBT EXTRACTION w/VACUUM抽提及/真空A

39、1K150 RFCS碳钢 -10to 260WET/HOT FLARE-10 至 260湿/热火炬 VENTS TO FLAREA1K20PN2.0RF(150RF)CS-10 to 260WET/HOT FLAREA1NR150 RFCS-10 TO 110SPENT CAUSTIC废碱-STRESS-10至110(50%Caustic碱),RELIEVED(50%碱),碳钢HYDROCARBON(WITH CAUSTIC&5%BENZENE已除应力烃(其中碱&5%苯)A1NR20PN2.0RF(150RF)CS-20 TO 110SPENT CAUSTIC (50%Caustic)A1P1

40、50 RFCS碳钢-10 TO 427TRANSFER LINES传送管线-10至 427HYDROCARBON 烃A1PA150 RFCS碳钢-10 TO 427(FULLVACUUMDECOKING LINES,脱焦管线-10至427(全真空)VACUUM SERVICES负压介质A1WR150 RFCS-10 TO 260STABILIZER COLUMN OVHD(H2S ENVIRONMENT)-10 至260稳定器塔塔顶(H2S环境)A1X150 RFCS碳钢-10 TO 371PROCESS LIQUID&VAPOUR(LETHAL W/HCN),-10 至371工艺液体及蒸汽(

41、致命性物料及HCN),OFFTEST ACRYLONITRILE未检验丙烯腈PARTIAL VAC CLOSED DRN部分负压倒淋关闭,LIQUID&VAPOUR(LETHAL-5.7PAIS)液体及蒸汽(致命物料-5.7PAIS)A1Y150 RFCS碳钢-10 TO 371PROCESS VAPOUR LETHAL(FULL VAC,ACRYLO&WTR)-10 至 371工艺蒸汽致命性物料(全负压,丙烯腈及水),CATALYST(FULL VAC AT CATALYST HOPPERS)催化剂(催化剂料斗全负压)A2A150 RFLTCS-46 TO 260COLD FLARE冷火炬,

42、ETHYLENE REFRIG.制冷乙烯,L.T.HYDROCARBON低温烃,-46至 260LIQUID DRAIN液体倒淋,PPL REFRIGERANT制冷剂A6A150 RFLINED CS -17to 93CHLORINATED WATER含氯水衬碳钢CHLORINE DIOXIDE二氧化氯DILUTE H2SO4 PARTIAL FLOW W/AIR,稀释液H2SO4 部分液流及/空气FERRIC CHLORIDE氯化铁,SODIUM CHLORIDE氯化钠,SODIUM BISULFITE二硫化钠,SODIUMHYPOCHLORITE ACID DRAINS(98%H2S04)

43、SULFURIC ACID(A/GRD only)次氯酸钠倒淋(98%H2S04)硫酸(仅A/GRD)HYDROCHLORIC ACID(31%)A6A20PN2.0RF(150RF)LINED CS(PVDF)-20 TO 93CHLORINATED WATER CHLORINE DIOXIDEDILUTE H2SO4 PARTIAL FLOW W/AIRFERRIC CHLORIDE SODIUM CHLORIDESODIUM BISULFITE SODIUM HYPOCHLORITEACID DRAINS(98%H2S04)SULFURIC ACID(A/GRD only)HYDROCH

44、LORIC ACID(31%)A21A150RFLJ304 SS-29 TO 204DEMINERALIZED WATER(NON-DEAERATED BFW)150 RFCS碳钢-29 至 204脱盐水(非脱氧BFW)A21A19PN2.0RF 1500Cr19Ni9S/Stl-29 TO204DEMINERALIZED WATER(NON-DEAERATED BFW)A21B150RFWN304 SS-29 TO 204BIOCIDE SOLUTION除菌溶液CORROSION INHIBITOR防腐剂DISPERSANT扩散剂,PHOSPHATE磷酸盐,NSIA21B19PN2.0RFL

45、J(150#)0Cr19Ni9S/Stl-29 TO204BIOCIDE SOLUTION除菌溶液CORROSION INHIBITOR防腐剂DISPERSANT扩散剂,PHOSPHATEA21C150RFLJ304 SS-29 TO 204HYDRAZINE肼A21D150RFLJ304 SS-29 TO 204LUBE AND SEAL OIL润滑及密封油(HIGH AND LOW PRESSURE)高压和低压A21K150RFWN304 SS-101 TO 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃(IMPACT-101至 20

46、4A21K19PN2.0RFWN(150RF)0Cr19Ni9S/Stl(IMPACTTESTED)-101 TO 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃A21L150RFWN304 SS-196 TO204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃-196至204A21L19PN2.0RFWN(150RF)0Cr19Ni9S/Stl-196 TO 204DRY FLARE干火炬,LIQUID DRAIN液体倒淋,L.T.HYDROCARBON低温烃A22A150RFLJ304

47、(L)SS-29 TO 160GASEOUS OXYGEN PROCESS LIQUID/VAPOURCLOSED DRAIN304(L)SS29至 160气态氧工艺流体蒸汽倒淋关闭304(L)SS-29 至288REACTOR EFFLUENT反应器排出物A22D150RFLJ304(L)SS-13 TO 150POWDER&PELLET CONVEYING 304(L)SS-13 至150粉粒料传输A22E150RFLJ304(L)SS-13 TO 140POWDER&PELLET粉及粒料(GRAVITY重力传输),304(L)SS-13 至 140粉及粒料(重力传输)POLYETHYLE

48、NE PELLET聚乙烯粒料PELLET ADDITIVE粒料添加剂A22F150RFWN304(L)SS-13 TO 65CATALYST CONVEYING VENT304(L)SS-13至 65催化剂输送放空,POLYSTYRENE VENT聚苯乙烯放空A22G150RFLJ304(L)SS-13 TO 140POWDER&PELLET(GRAVITY)304(L)SS-13至 140粉粒料(重力传输)CONVEYING AIR传输空气A22H150RFLJ304(L)SS-13 TO140POWDER/PELLET(GRAVITY LINES)粉粒料304(L)SS-13至 140粉粒

49、料(重力传输管线)PELLET ADDITIVE粒料添加剂POWDER粉料,POLYETHYLENE PELLET聚乙烯粒料A23L150RFLJ316(L)SS0 TO 300SOFTENED WATER软化水COLD DEMIN WATER冷却脱盐水STYRENE苯乙烯A23L17PN2.0RFLJ(150#)00Cr17Ni14Mo2S/Stl0 TO 300SOFTENED WATER COLD DEMIN WATERSTYRENEA21A150RFLJ304 SSA24A150RFLJ316(L)SS-29 TO 160SULPHUR DIOXIDE 二氧化硫(DRY干态)316(L

50、)SS-29 至160二氧化硫(干态)A24B150RFLJ316(L)SSDUAL-29 TO 177AMINE胺,316(L)SS-29 至 177PHOSPHATE磷酸盐,双重认证MAC +H2O M酸+H2OCRUDE&WEAK MAC原M酸及弱M酸ACRYLIC/ACETIC ACID丙烯酸/醋酸A24B17PN2.0RFLJ(150#)00Cr17Ni14Mo2S/Stl-29 TO200AMINE胺,PHOSPHATE磷酸盐,MAC +H2O M酸+H2OCRUDE&WEAK MAC原M酸及弱M酸ACRYLIC/ACETIC ACID丙烯酸/醋酸A24C150 RF316(L)S