Y系列Y2系列电动机主要全参数表.pdf

《Y系列Y2系列电动机主要全参数表.pdf》由会员分享，可在线阅读，更多相关《Y系列Y2系列电动机主要全参数表.pdf（9页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、.Y Y 系列，系列，Y2Y2 系列电动机主要参数表系列电动机主要参数表Y 系列电动机是一般用途的全封闭自扇冷式鼠笼型三相异步电动机。安装尺寸和功率等级符合 IEC 标准，外壳防护等级为 IP44，冷却方法为 IC411，连续工作制（S1）。适用于驱动无特殊要求的机械设备，如机床、泵、风机、压缩机、搅拌机、运输机械、农业机械、食品机械等。Y 系列电动机效率高、节能、堵转转矩高、噪音低、振动小、运行安全可靠。Y80315 电动机符合 Y 系列（IP44）三相异步电动机技术条件 JB/T9616-1999。Y355 电动机符合 Y 系列（IP44）三相异步电动机技术条件 JB5274-91。Y80

2、315 电动机采用 B 级绝缘。Y355 电动机采用 F 级绝缘。额定电压为 380V，额定频率为 50Hz。功率 3kW及以下为 Y 接法；其它功率均为接法。电动机运行地点的海拔不超过 1000m；环境空气温度随季节变化，但不超过 40；最低环境空气温度为-15；最湿月月平均最高相对湿度为90%；同时该月月平均最低温度不高于 25。;.型型号号堵转转矩堵转转矩功率功率转速转速效效率率功率功率电流电流因数因数额定转矩额定转矩额定额定额定额定kWkWA Ar/minr/min%COSCOS倍倍堵转电流堵转电流额定电流额定电流倍倍最大转矩最大转矩额定转矩额定转矩倍倍噪声噪声1 1 级级2 2 级级

3、dB(A)dB(A)振动振动速度速度mm/smm/s重量重量kgkg同步转速3000r/min2级Y80M1-2Y80M1-2Y80M2-2Y80M2-2Y90S-2Y90S-2Y90L-2Y90L-2Y100L-2Y100L-2Y112M-2Y112M-2Y132S1-2Y132S1-2Y132S2-2Y132S2-2Y160M1-2Y160M1-2Y160M2-2Y160M2-2Y160L-2Y160L-2Y180M-2Y180M-2Y200L1-2Y200L1-2Y200L2-2Y200L2-2Y225M-2Y225M-2Y250M-2Y250M-2Y280S-2Y280S-2Y280M

4、-2Y280M-2Y315S-2Y315S-2Y315M-2Y315M-2Y315L1-2Y315L1-2Y315L2-2Y315L2-2Y355M1-2Y355M1-2Y355M2-2Y355M2-2Y355L1-2Y355L1-2Y355L2-2Y355L2-20.751.11.52.2345.57.5111518.5223037455575901101321602002202502803151.82.53.44.86.48.211.11521.829.435.542.256.969.88410313916620324229236539944749956028302830284028402

5、88028902900290029302930293029402950295029702970297029702980298029802980298029852985298575.077.078.080.582.085.585.586.287.288.289.089.090.090.591.591.592.092.592.593.093.593.594.294.594.795.00.840.860.850.860.870.870.880.880.880.880.890.890.890.890.890.890.890.890.890.890.890.890.890.900.900.902.22.

6、22.22.22.22.22.02.02.02.02.02.02.02.02.02.02.02.01.81.81.81.81.21.21.21.26.57.07.07.07.07.07.07.07.07.07.07.07.07.07.07.07.07.06.86.86.86.86.97.07.17.12.32.32.32.32.32.32.32.32.32.32.22.22.22.22.22.22.22.22.22.22.22.22.22.22.22.266667070747478788282828790909092949499999999717175757979838387878792959

7、5979799991041041041041.81.81.81.81.81.81.81.82.82.82.82.82.82.82.84.54.54.54.54.54.54.54.54.54.54.517182225344567721151251451732322503123875155669221010108512201710175019002105109111111111同步转速1500r/min4级Y80M1-4Y80M1-4Y80M2-4Y80M2-4Y90S-4Y90S-4Y90L-4Y90L-4Y100L1-4Y100L1-4Y100L2-4Y100L2-4Y112M-4Y112M-

8、4Y132S-4Y132S-40.550.751.11.52.2345.57.5111518.51.522.73.756.88.811.615.422.630.335.913901390140014001430143014401440144014601460147073.074.578.079.081.082.584.585.587.088.088.591.00.760.760.780.790.820.810.820.840.850.840.850.862.42.32.32.32.22.22.22.22.22.22.22.06.06.06.56.57.07.07.07.07.07.07.07.

9、02.32.32.32.32.32.32.32.32.32.32.32.25656616265656870717577776767676770707478788282821.81.81.81.81.81.81.81.81.81.81.81.8171725263435476879122142174;.Y132M-4Y132M-4Y160M-4Y160M-4Y160L-4Y160L-4Y180M-4Y180M-4.Y180L-4Y180L-4Y200L-4Y200L-4Y225S-4Y225S-4Y225M-4Y225M-4Y250M-4Y250M-4Y280S-4Y280S-4Y280M-4Y2

10、80M-4Y315S-4Y315S-4Y315M-4Y315M-4Y315L1-4Y315L1-4Y315L2-4Y315L2-4Y355M1-4Y355M1-4Y355M3-4Y355M3-4Y355L2-4Y355L2-4Y355L3-4Y355L3-42230374555759011013216020022025028031542.556.870.484.210314016420124028936140746151557814701470148014801480148014801480148014801480148814881488148891.592.291.892.392.692.7

11、93.593.594.094.594.594.494.794.995.20.860.870.870.880.880.880.890.890.890.890.890.870.870.870.872.02.01.91.92.01.91.91.81.81.81.81.41.41.41.47.07.07.07.07.07.07.06.86.86.86.86.86.86.86.92.22.22.22.22.22.22.22.22.22.22.22.22.22.22.2777979798185859396969682848484869090981011011011.81.81.81.82.82.82.82

12、.82.82.82.84.54.54.54.51922532943273815356349121048110512601690180019451985106108108108同步转速1000r/min6 级Y90S-6Y90S-6Y90L-6Y90L-6Y100L-6Y100L-6Y112M-6Y112M-6Y132S-6Y132S-6Y132M1-6Y132M1-6Y132M2-6Y132M2-6Y160M-6Y160M-6Y160L-6Y160L-6Y180M-6Y180M-6Y200L1-6Y200L1-6Y200L2-6Y200L2-6Y225M-6Y225M-6Y250M-6Y250

13、M-6Y280S-6Y280S-6Y280M-6Y280M-6Y315S-6Y315S-6Y315M-6Y315M-6Y315L1-6Y315L1-6Y315L2-6Y315L2-6Y355M1-6Y355M1-6Y355M2-6Y355M2-6Y355M4-6Y355M4-6Y355L1-6Y355L1-6Y355L3-6Y355L3-60.751.11.52.2345.57.5111518.5223037455575901101321601852002202502.33.245.67.29.412.61724.631.437.744.659.57285.410414116920624630

14、034737541146691091094094096096096097097097097098098098098098098098098098099099099099199172.573.577.580.583.084.085.386.087.089.589.890.290.290.892.092.092.893.293.593.894.194.394.394.594.70.70.70.70.70.80.80.80.80.80.80.80.80.90.90.90.90.90.90.90.90.90.90.90.90.92.02.02.02.02.02.02.02.02.01.81.81.81

15、.71.81.81.81.61.61.61.61.31.31.31.31.35.55.56.06.06.56.56.56.56.56.56.56.56.56.56.56.56.56.56.56.56.76.76.76.76.72.22.22.22.22.22.22.22.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.0565662626666666970707373767679798787878765656767717171757578787881818484929292921.81.81.81.81.81.81.81.81.81.81.

16、81.81.82.82.82.82.82.82.82.84.54.54.54.54.521243545667585116139182228246294395505568509651028119515901665172517801865102102102102105同步转速750r/min8 级Y132S-8Y132S-82.25.871080.50.72.05.52.061661.866;.Y132M-8Y132M-8Y160M1-8Y160M1-8Y160M2-8Y160M2-8Y160L-8Y160L-8Y180L-8Y180L-8Y200L-8Y200L-8Y225S-8Y225S-8Y

17、225M-8Y225M-8Y250M-8Y250M-8Y280S-8Y280S-8Y280M-8Y280M-8Y315S-8Y315S-8Y315M-8Y315M-8Y315L1-8Y315L1-8Y315L2-8Y315L2-8Y355M2-8Y355M2-8Y355M4-8Y355M4-8Y355L3-8Y355L3-8Y355L4-8Y355L4-8345.57.5111518.5223037455575901101321601852007.79.913.317.724.834.141.347.66378.293.2114152179218264319368398710720720720

18、73073073073073074074074074074074074074074274382.084.085.086.087.588.089.590.090.591.091.792.092.593.093.393.894.094.294.30.70.70.70.80.80.80.80.80.80.80.80.80.80.80.80.80.80.80.82.02.02.02.01.71.81.71.81.81.81.81.61.61.61.61.31.31.31.35.56.06.05.56.06.06.06.06.06.06.06.56.56.56.36.36.36.36.32.02.02.

19、02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.0616464676770707073737382828282666969697272757575787887878787999999991.81.81.81.81.81.81.81.81.82.82.82.82.82.82.84.54.54.54.5761051151401802282652963915005628751008106511951675173018401905同步转速600r/min10 级Y315S-10Y315S-10Y315M-10Y315M-10Y315L2-10Y315L2

20、-10Y355M1-10Y355M1-10Y355M2-10Y355M2-10Y355L1-10Y355L1-104555759011013210112316419123027559059059059559559591.592.092.593.093.293.50.70.70.80.80.80.81.41.41.41.21.21.26.06.06.06.06.06.02.02.02.02.02.02.08282828787879696962.82.82.84.54.54.58389601180162017751880Y2 系列电动机是 Y 系列电机的更新换代产品，是一般用途的全封闭自扇冷式鼠笼

21、型三相异步电动机。它是我国九十年代最新产品，其整体水平已达到国外同类产品九十年代初的水平。该产品应用于国民经济各个领域，如机床、水泵、风机、压缩机，也可适用于运输、搅拌、印刷、农机、食品等各类不含易燃、易爆或腐蚀性气体的场合。Y2 系列电机的安装尺寸和功率等级符合 IEC 标准，与德国DIN42673 标准一致，也与 Y 系列电机一样，其外壳防护等级为 IP54，冷却方法为 IC41l，连续工作制（S1）。采用F 级绝缘，温升按B 级;.考核(除 315L2-2、4，355 全部规格按 F 级考核外)，并要求考核负载噪声指标。Y2 系列电动机额定电压为 380V，额定频率为 50Hz。功率 3

22、kwt以下为 Y 接法，其他功率均为接法。电动机运行地点的海拔不超过 1000m；环境空气温度随季节变化，但不超过 40；最低环境空气温度为-15；最湿月月平均最高相对湿度为90%；同时该月月平均最低温度不高于 25。Y2 系列电动机有两种设计，一种是适用于一般机械配套和出口需要，在轻载时有较高效率，在实际运行中有较佳节能效果，且具有较高堵转转矩，此设计称为 Y2-Y 系列。中心高 63355mm，功率从0.12315kW。电动机符合 JB/T8680.1-1998 Y2 系列(1P54)三相异步电动机（机座号 63355）技术条件。型号含义：如 Y2-200L1-2Y：“Y2”表示异步电动机

23、第二次改型设计，“200”表示中心高，“L”表示机座长短号，“1”表示铁心长度序号，“2”表示极数，“Y”表示第一种设计（可省略）。第 2 种设计是满载时有较高效率，更适用于长期运行和负载率较高的使用场合，如水泵、风机配套，此设计称为Y2-E 系列，中心高80280mm，功率从 0.5590kW。电动机符合 JB/T8680.2-1998 Y2 系列(1P54)三相异步电动机（机座号 80280）技术条件。型号含义：如 Y2-200L2-6E：“Y2”表示异步电动机第二次改型设计，“200”表示中心高，“L”表示机座长短号，“2”表示铁心长度序号，“6”表示极数，“E”表示第二种设计。;.最大

24、转最小转堵转转堵转电额定功额定电型号率流转速效率功率因数矩矩矩流噪声振动速度载差dB(A)mm/s额定转额定转额定转额定电空空负载之矩矩倍矩倍流倍kWAr/min%cos倍2极Y2-63M1-20.18Y2-63M2-20.25Y2-71M1-20.37Y2-71M2-20.55Y2-80M1-20.75Y2-80M2-2Y2-90S-2Y2-90L-2Y2-100L-2Y2-112M-2Y2-132S1-2Y2-132S2-2Y2-160M1-2Y2-160M2-21.11.52.2345.57.511150.50.71.01.41.82.63.44.96.38.111.014.921.33

25、8.834.741.055.567.982.32820 65.02820 68.02820 70.02820 73.02830 75.02830 77.02840 79.02840 81.02880 83.02890 85.02900 86.02900 87.02930 88.02930 89.02930 90.02940 90.02950 91.22950 92.02960 92.30.800.810.810.820.830.840.840.850.870.880.880.880.890.890.900.900.900.900.900.900.900.910.910.910.920.920.

26、920.922.22.2.2.22.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.22.22.22.22.22.24极Y2-63M1-40.12Y2-63M2-40.18Y2-71M1-40.25Y2-71M2-40.370.40.60.81.01370 57.01370 60.01380 65.01380 67.00.720.730.740.752.22.22.22.21.71.71.71.72.12.12.12.14.44.45.25.25252555555551.81.81.81.81.61.61.61.61.51.51

27、.51.41.41.41.21.21.21.21.11.11.11.11.01.00.90.90.90.90.90.80.80.82.22.22.22.22.22.22.22.22.22.22.22.22.22.22.22.02.02.02.02.02.02.01.81.81.81.81.61.65.55.56.16.16.17.07.07.07.57.57.57.57.57.57.57.57.57.57.57.57.57.57.17.17.17.17.17.16161646467677272767780808686868992929293949496969999103103222222222

28、22222222222222222221.81.81.81.81.81.81.81.81.81.81.81.82.82.82.82.82.82.82.83.53.53.53.53.53.53.53.53.5Y2-160L-218.5Y2-180M-2Y2-200L1-2Y2-200L2-2Y2-225M-2Y2-250M-2Y2-280S-2Y2-280M-222303745557590101.02970 92.5134.42970 93.0160.22970 93.8195.02980 94.02332980 94.52792980 94.63482980 94.84332980 95.35

29、442980 95.6Y2-315S-2110Y2-315M-2132Y2-315L1-2160Y2-315L2-2200Y2-355M-2250Y2-355L-2315;.Y2-80M1-40.55Y2-80M2-40.75Y2-90S-4Y2-90L-4Y2-100L1-4Y2-100L2-4Y2-112M-4Y2-132S-4Y2-132M-4Y2-160M-4Y2-160L-41.11.52.2345.57.511151.62.02.93.75.26.88.811.815.622.330.136.543.257.669.984.71390 71.01390 73.01400 75.01

30、400 78.01430 80.01430 82.01440 84.01440 85.01440 87.01460 88.01460 89.01470 80.51470 91.01470 92.01475 92.51475 92.80.750.760.770.790.810.820.820.830.840.840.850.860.860.860.870.870.870.870.870.880.880.890.890.900.902.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.32.22.22.22.22.22.26极1.71.61

31、.61.61.51.51.51.41.41.41.41.21.21.21.21.11.11.01.01.01.01.00.90.90.82.42.32.32.32.32.32.32.32.32.22.22.22.22.22.22.22.22.22.22.12.12.12.12.12.15.26.06.06.07.07.07.07.07.07.07.57.57.57.27.27.27.27.27.26.96.96.96.96.96.9585860606464657171757576767981818386869393979710110155555555554444433333333331.81.

32、81.81.81.81.81.81.81.82.82.82.82.82.82.82.83.53.53.53.53.53.53.53.53.5Y2-180M-418.5Y2-180L-4Y2-200L-4Y2-225S-4Y2-225M-4Y2-250M-4Y2-280S-4Y2-280M-422303745557590103.01480 93.0139.61480 93.8166.91480 94.22011480 94.52401480 94.82871480 94.93591480 95.04431480 95.35561480 95.6Y2-315S-4110Y2-315M-4132Y2

33、-315L1-4160Y2-315L2-4200Y2-355M-4250Y2-355L-4315Y2-71M1-60.18Y2-71M2-60.25Y2-80M1-60.37Y2-80M2-60.55Y2-90S-60.75Y2-90L-6Y2-100L-6Y2-112M-6Y2-132S-6Y2-132M1-6Y2-132M2-6Y2-160M-6Y2-160L-6Y2-180M-61.11.52.2345.57.511150.71.01.31.82.33.23.95.67.49.812.917.024.231.690056.090059.090062.090065.091069.09107

34、2.094076.094079.096081.096082.096084.097086.097087.597089.00.660.680.70.720.720.730.750.760.760.760.770.770.780.812222.12.12.12.12.12.12.12.12.12.12.11.51.51.51.51.51.31.31.31.31.31.31.31.21.21.91.91.91.922222.12.12.1222444.74.75.55.55.56.56.56.56.56.56.57.0525254545757616569696973737377777777777776

35、1.81.81.81.81.81.81.81.81.81.81.82.82.82.8;.Y2-200L1-618.5Y2-200L2-6Y2-225M-6Y2-250M-6Y2-280S-6Y2-280M-6Y2-315S-6Y2-315M-62230374555759038.644.759.371.085.998090.098090.098091.598092.098092.50.810.830.840.860.860.860.860.860.860.870.880.880.882.12.12.12.12.02.02.02.02.02.02.02.02.08极1.21.21.21.21.11

36、.11.01.01.01.01.00.90.92.12.122.12.12.122221.91.91.97.07.07.07.07.07.07.07.06.76.76.76.76.77676767880808585858592929266665555544442.82.82.83.53.53.53.53.53.53.53.53.53.5104.798092.814116920624429236545598093.598093.898094.098094.298094.598094.798094.9Y2-315L1-6110Y2-315L2-6132Y2-355M1-6160Y2-355M2-6

37、200Y2-355L-6250Y2-80M1-80.18Y2-80M2-80.25Y2-90S-80.37Y2-90L-80.55Y2-100L1-80.75Y2-100L2-8Y2-112M-8Y2-132S-8Y2-132M-8Y2-160M1-8Y2-160M2-8Y2-160L-8Y2-180L-8Y2-200L-81.11.52.2345.57.511150.91.21.52.22.43.44.56.07.910.313.617.825.134.141.447.464.077.894.170051.070054.070062.070063.070071.070073.071075.0

38、71078.071079.072081.072083.072085.573087.573088.073090.073090.573091.074091.574092.00.610.610.610.610.670.690.690.710.730.730.740.750.700.760.760.780.790.790.790.810.810.820.820.820.820.831.91.91.92.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.02.01.31.31.31.31.31.21.21.21.21.21.21

39、.21.21.11.11.11.11.11.01.00.90.90.90.90.90.91.81.81.81.81.81.81.81.81.81.92.02.02.02.01.91.91.91.91.91.81.81.81.81.81.81.83.33.34.04.04.05.05.05.06.06.06.06.06.66.66.66.66.66.66.66.66.66.66.46.46.46.452525656595961646468686870737373757676828282829090908888888888888777776366665551.81.81.81.81.81.81.8

40、1.81.82.82.82.82.82.82.82.83.53.53.53.53.53.53.53.53.53.5Y2-225S-818.5Y2-225M-8Y2-250M-8Y2-280S-8Y2-280M-8Y2-315S-8Y2-315M-8Y2-315L1-82230374555759011174092.815174093.017874093.821774094.026174093.731574094.238874094.5Y2-315L2-8110Y2-355M1-8132Y2-355M2-8160Y2-355L-8200;.10极Y2-315S-10Y2-315M-10Y2-315L1-10Y2-315L2-104555759010059091.512159092.016259092.519159093.023059093.227559093.533459093.50.750.750.760.770.780.780.782.02.02.02.02.02.02.00.80.80.80.80.80.80.81.51.51.51.51.31.31.36.26.26.26.26.06.06.0828282829090907777763.53.53.53.53.53.5Y2-355M1-10110Y2-355M2-10132Y2-355L-10160;.