第8章气体吸收 81概述精选PPT.ppt

《第8章气体吸收 81概述精选PPT.ppt》由会员分享，可在线阅读，更多相关《第8章气体吸收 81概述精选PPT.ppt（26页珍藏版）》请在淘文阁 - 分享文档赚钱的网站上搜索。

1、第8章气体吸收 81概述第1页，本讲稿共26页 A concentration gradient tends to move the component in such a direction as to equalize concentrations and destroy the gradient.浓度梯度驱使扩浓度梯度驱使扩散组分朝着使浓散组分朝着使浓度均匀化的方向度均匀化的方向扩散，从而使浓扩散，从而使浓度梯度趋于消失。度梯度趋于消失。第2页，本讲稿共26页vWhen the gradient is maintained by constantly supplying the diff

2、using component to the high-concentration end of the gradient and removing it at the low concentration end,there is a steady-state flux of the diffusing component.This is characteristic of many mass-transfer operations.当不断地向当不断地向高浓度一端提供高浓度一端提供扩散组分，从低扩散组分，从低浓度一端除去扩浓度一端除去扩散组分时，扩散散组分时，扩散组分便具有稳定组分便具有稳定的

3、传质通量。这的传质通量。这就是许多传质操就是许多传质操作的特点。作的特点。第3页，本讲稿共26页例如，当在填料塔例如，当在填料塔中用水吸收气体中中用水吸收气体中的的NHNH3 3时，在塔内的时，在塔内的任意一点上，在气任意一点上，在气相浓度梯度的驱使相浓度梯度的驱使下，下，NHNH3 3由气相主体由气相主体扩散至气液界面，扩散至气液界面，在界面上溶解，然在界面上溶解，然后，在液相浓度梯后，在液相浓度梯度驱使下，扩散至度驱使下，扩散至液相主体。液相主体。For example,when ammonia is removed from a gas by absorption in water in

4、 a packed column,at each point in the column a concentration gradient in the gas phase causes ammonia to diffuse to the gas-liquid interface,where it dissolves,and a gradient in the liquid phase causes it to diffuse into the bulk liquid.第4页，本讲稿共26页In stripping a solute from a liquid the gradients ar

5、e reversed;here diffusion brings solute from the bulk liquid to the interface and from there into the gas phase.当从吸收液中解当从吸收液中解吸溶质时，浓度吸溶质时，浓度梯度与吸收过程梯度与吸收过程相反。在此，扩相反。在此，扩散作用使溶质从散作用使溶质从液相主体移至界液相主体移至界面，再从界面移面，再从界面移至气相。至气相。第5页，本讲稿共26页In some other mass-transfer operations such as leaching and adsorption,

6、unsteady-state diffusion takes place,and the gradients and fluxes decrease with time as equilibrium is approached.在其它一些诸如浸在其它一些诸如浸取和吸咐操作中发取和吸咐操作中发生的是不稳定扩散，生的是不稳定扩散，随着过程趋于平衡，随着过程趋于平衡，扩散组分的浓度梯扩散组分的浓度梯度和通量随时间而度和通量随时间而降低。降低。第6页，本讲稿共26页Although the usual cause of diffusion is a concentration gradient,dif

7、fusion can also be caused by an activity gradient,as in reverse osmosis,by a pressure gradient,by a temperature gradient,or by the application of an external force field,as in a centrifuge.虽然扩散的一般虽然扩散的一般原因是浓度梯度，但原因是浓度梯度，但能动梯度也能引起扩能动梯度也能引起扩散如反渗透过程，压散如反渗透过程，压力梯度、温度梯度和力梯度、温度梯度和外场力都可引起扩散，外场力都可引起扩散，如离心分离

8、。如离心分离。第7页，本讲稿共26页Molecular diffusion induced by temperature is thermal diffusion,and that from an external field is forced diffusion.Both are uncommon in chemical engineering.Only diffusion under a concentration gradient is considered in this chapter.由温度引起的分子由温度引起的分子扩散称为热扩散，扩散称为热扩散，由外场力引起的扩由外场力引起的扩

9、散称为强制扩散。散称为强制扩散。这两种扩散方式在这两种扩散方式在化学工程中并不常化学工程中并不常见。本章仅讨论由见。本章仅讨论由浓度梯度引起的质浓度梯度引起的质量扩散。量扩散。第8页，本讲稿共26页Diffusion is not restricted to molecular transfer through stagnant layers of solid or fluid.It also takes place when fluids of different compositions are mixed.扩散并不局限扩散并不局限于分子通过固体或于分子通过固体或液体停滞膜的传递。液体停滞

10、膜的传递。当不同组成的流体当不同组成的流体相混合时也会发生相混合时也会发生扩散。扩散。第9页，本讲稿共26页 The first step in mixing is often mass transfer caused by the eddy motion characteristic of turbulent flow.This is called eddy diffusion.The second step is molecular diffusion between and inside the very small eddies.混合过程首先混合过程首先是因湍流的涡流特是因湍流的涡流特

11、性引起的质量传递。性引起的质量传递。这一过程被称为涡这一过程被称为涡流扩散。其次是在流扩散。其次是在微小的漩涡间及其微小的漩涡间及其内部的分子扩散。内部的分子扩散。第10页，本讲稿共26页 Sometimes the diffusion process is accompanied by bulk flow of the mixture in a direction parallel to the direction of diffusion.有时扩散过程有时扩散过程还伴随着与扩散还伴随着与扩散方向相平行的混方向相平行的混合物主体流动。合物主体流动。第11页，本讲稿共26页In all the

12、 mass-transfer operations,diffusion occurs in at least one phase and often in both phases.In distillation,the low boiler diffuses through the liquid phase to the interface and away from the interface into the vapor.在所有的质量传递在所有的质量传递操作中，扩散至少操作中，扩散至少在一相中发生，更在一相中发生，更多则是在两相中发多则是在两相中发生。蒸馏时，低沸生。蒸馏时，低沸物由液相扩

13、散至界物由液相扩散至界面，离开界面进入面，离开界面进入汽相。汽相。Role of diffusion in mass transfer扩散在质量传递中的角色扩散在质量传递中的角色第12页，本讲稿共26页 The high boiler diffuses in the reverse direction and passes through the vapor into the liquid.In leaching,diffusion of solute through the solid phase is followed by diffusion into the liquid.高沸物逆向扩

14、高沸物逆向扩散从汽相进入液相。散从汽相进入液相。浸取时，溶质扩散浸取时，溶质扩散穿过固相，然后再穿过固相，然后再扩散进入液相。扩散进入液相。第13页，本讲稿共26页 In liquid extraction,the solute diffuses through the raffinate phase to the interface and then into the extract phase.In crystallization,solute diffuses through the mother liquor to the crystals and deposits on the so

15、lid surfaces.液液萃取时，液液萃取时，溶质从萃余相扩散溶质从萃余相扩散至液液界面，然至液液界面，然后进入萃取相。结后进入萃取相。结晶时，溶质由母液晶时，溶质由母液扩散到晶体，然后扩散到晶体，然后积淀于晶体表面。积淀于晶体表面。第14页，本讲稿共26页 In humidification or dehumidification there is no diffusion through the liquid phase because the liquid phase is pure and no concentration gradient through it can exist

16、;but the vapor diffuses to or from the liquid-gas interface into or out of the gas phase.增湿和减湿时，增湿和减湿时，因液相是纯液体，因液相是纯液体，无浓度梯度存在。无浓度梯度存在。故液相无扩散。但故液相无扩散。但增湿时，蒸汽离开增湿时，蒸汽离开气液界面，扩散进气液界面，扩散进入气相；而减湿时，入气相；而减湿时，则为蒸汽朝向气液则为蒸汽朝向气液界面，扩散离开气界面，扩散离开气相。相。第15页，本讲稿共26页 In membrane separations diffusion occurs in all th

17、ere phases:in the fluids on either side of the membrane and in the membrane itself.膜分离时，膜分离时，所有相中即膜两所有相中即膜两侧的流体中和膜侧的流体中和膜自身内均会发生自身内均会发生扩散现象。扩散现象。第16页，本讲稿共26页Chap.8 Gas absorptionThis chapter deals with the mass-transfer operations known as gas absorption and stripping or desorption.气体吸收气体吸收:利用利用气体混合

18、物气体混合物各组份在各组份在吸收剂吸收剂中的中的溶解度溶解度不同，不同，而使气体混合物得以而使气体混合物得以分离分离的单元操作。的单元操作。In gas absorption a soluble gas is absorbed from its mixture with an inert gas by means of liquid in which the solute gas is more or less soluble.8-1 Introduction第17页，本讲稿共26页 气体混合物：Mixture or Rich Gas A+B 溶质：Solute A 惰性气体：An Inert

19、 Gas B 吸收剂：Solvent S 溶解度：Solubility 分离：Separation 可溶的：Soluble 单元操作：Unit Operation 吸收液：Absorbing liquid or The strong liquid 尾气：Dilute gas or Lean gasKEY WORDS8-1 Introduction2 规定第18页，本讲稿共26页3 Examples（P546）A major application of absorption technology is the removal of CO2 and H2S from natural gas（天然

20、气）（天然气）or synthesis gas（合成气）（合成气）by absorption in solutions of amines（有机胺）（有机胺）or alkaline salts（碱式盐）（碱式盐）.Another example is the washing of ammonia from a mixture of ammonia and air by means of liquid water.8-1 Introduction第19页，本讲稿共26页4 The solute&the absorbing liquidThe solute is subsequently reco

21、vered from the liquid by distillation,and the absorbing liquid can be either discarded or reused.5 Adsorption sometimes a solute is removed from a liquid by bringing the liquid into contact with an inert gas;such an operation,the reverse of gas absorption,is desorption or gas stripping.8-1 Introduct

22、ion第20页，本讲稿共26页 A common apparatus used in gas absorption and certain other operations is the packed tower.The rich gas enters the distributing space below the packing and flows upward through the interstices(空隙空隙)in the packing countercurrent to the flow of the liquid.填料：填料：Packing 填料塔：填料塔：Packed t

23、ower6 The process of gas absorption8-1 Introduction第21页，本讲稿共26页 The packing provides a large area of contact between the liquid and gas and encourages intimate contact between the phases.The solute in the rich gas is absorbed by the fresh liquid entering the tower,and dilute,or lean,gas leaves the t

24、op.The liquid is enriched in solute as it flows down the tower,and concentrated liquid,called the strong liquid,leaves the bottom of the tower through the liquid outlet.8-1 Introduction第22页，本讲稿共26页7 Major applications for gas absorption in commercial industry Purification of the material gases 原料气净化

25、原料气净化 CO2 and H2S are removed from natural gas or synthesis gas by absorption in solutions of amines salts.在合成在合成NHNH3 3工艺中，来自变换工段的变换气工艺中，来自变换工段的变换气约含约含2828COCO2 2。因因C0C02 2可使可使catalyst中毒。所以，变中毒。所以，变换气进合成塔前，必须经过水洗和铜洗两个工段，换气进合成塔前，必须经过水洗和铜洗两个工段，将将COCO2 2的含量减小到的含量减小到0.010.01以下。以下。8-1 Introduction第23页，本

26、讲稿共26页Recovering of using materialsPreparation of some solution For examples:NO2 is absorbed by liquid water.HNO3 化学吸收化学吸收HCl is absorbed by liquid water.HCl 物理吸收物理吸收Purification of waste gas 8 Classification Absorption and absorption with chemical reaction 物理吸收与化学吸收物理吸收与化学吸收Isothermal absorption an

27、d no-isothermal absorption 等温吸收与非等温吸收等温吸收与非等温吸收8-1 Introduction第24页，本讲稿共26页 In general，当气体溶解于液体时，常常伴当气体溶解于液体时，常常伴随有溶解热。若有化学反应存在，还会有反应热。随有溶解热。若有化学反应存在，还会有反应热。这些因素最终导致溶液温度逐渐升高。但若这些因素最终导致溶液温度逐渐升高。但若热效热效应较小应较小，或，或气相中气相中A A的浓度很低，的浓度很低，或或吸收剂用量吸收剂用量很大很大时，温度升高不显著，便可以认为是时，温度升高不显著，便可以认为是Isothermal absorption。

28、Single and multiple component absorption 单组份吸收与多组份吸收单组份吸收与多组份吸收Single component:混合气中混合气中只有一个组份只有一个组份进入液相。进入液相。Multicomponent:混合气中有混合气中有两或更多组份两或更多组份进入液相。进入液相。This chapter deals with the isothermal single absorption。8-1 Introduction第25页，本讲稿共26页9 This chapter will discuss some questions:吸收过程进行的限度和影响因素吸

29、收过程进行的限度和影响因素 Phase-equilibrium 相平衡相平衡吸收剂用量的计算（操作型问题）吸收剂用量的计算（操作型问题）Calculation of amount of the liquid吸收塔高度的计算吸收塔高度的计算（设计型问题）（设计型问题）Calculation of tower height提高吸收塔生产能力的措施提高吸收塔生产能力的措施 Methods to enhance the ability of absorption tower10 10 吸收设备吸收设备吸收设备有多种结构。吸收设备有多种结构。但以但以塔设备塔设备最为常用。最为常用。填料塔填料塔packed tower 板式塔板式塔plate tower8-1 Introduction第26页，本讲稿共26页